2005 Toyota Celica Owners Manual

Make sure the rubber cover fits securely on the bulb base and the mounting body. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

253

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

—High beam headlights (without discharge headlights)

1. Open the hood. RIGHT SIDE HEADLIGHT—Remove the clips and take out the cover. In doing so, remove the washer hose from the notch on the cover. Remove and install shown in the following illustrations.

the cover clips as

5. RIGHT SIDE HEADLIGHT—Install the

cover.

NOTICE

Always notch the washer hose before fastening it when installing the cover. This prevents washer hose damage.

254

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Removing clip

2. Turn the bulb base counterclockwise

and remove it.

3. Pull the bulb out of the bulb base

and install a new bulb.

If the connector is tight, wiggle it.

Installing clip

255

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

—Front fog and front side marker lights If either the left or right front fog or front side marker lights burns out, con- tact your Toyota dealer.

NOTICE

Do not try to replace the front fog or front side marker light bulbs by your- self. You may damage the vehicle.

4. Insert the bulb base into the mount-

ing hole by turning it clockwise.

Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

5. RIGHT SIDE HEADLIGHT—Install the

cover.

NOTICE

Always notch the washer hose before fastening it when installing the cover. This prevents washer hose damage.

256

2005 CELICA from Sep. ’04 Prod. (OM20888U)

—Parking lights

’05MY CELICA U (L/O 0409)

RIGHT SIDE PARKING LIGHT—Remove and install the clips as shown in the following illustrations.

NOTICE

Always notch the washer hose before fastening it when installing the cover. This prevents washer hose damage.

Removing clip

Installing clip

257

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

—Front turn signal lights

RIGHT SIDE FRONT TURN SIGNAL LIGHT—Remove and install the clips as shown in the following illustrations.

NOTICE

Always notch the washer hose before fastening it when installing the cover. This prevents washer hose damage.

258

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

—Rear turn signal, stop/tail and rear side marker, and back−up lights

259

2005 CELICA from Sep. ’04 Prod. (OM20888U)

Removing clip

Installing clip

’05MY CELICA U (L/O 0409)

—License plate lights

a: Stop/tail and rear side marker light b: Back−up light c: Rear turn signal light

Use a Phillips−head screwdriver.

260

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

SECTION 8

SPECIFICATIONS Specifications Dimensions and weights Engine Fuel Service specifications Tires Fuses

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

262
262
262
263
265
266

261

2005 CELICA from Sep. ’04 Prod. (OM20888U)

Dimensions and weights Overall length Overall width Overall height Wheelbase Front tread Rear tread Vehicle capacity weight (occupants + luggage)

mm (in.) mm (in.) mm (in.) mm (in.) mm (in.) mm (in.)

4330 (170.5) 1735
(68.3) (51.8)∗ 1305
2600 (102.4) (58.7) 1490
1480
(58.3)

kg (lb.)

329

(725)

Towing capacity (trailer weight + cargo weight)

∗: Unladen vehicle

kg (lb.)

907 (2000)

262

’05MY CELICA U (L/O 0409)

Engine Model:

1ZZ−FE and 2ZZ−GE

Type:

4 cylinder in line, 4 cycle, gasoline

Bore and stroke, mm (in.):

1ZZ−FE engine

79.0 91.5 (3.11 3.60)

2ZZ−GE engine

82.0 85.0 (3.23 3.35)

Displacement, cm3 (cu. in.):

Fuel Fuel type:

1ZZ−FE engine

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher

2ZZ−GE engine

Select premium unleaded gasoline with an Octane Rating of 91 (Research Oc- tane Number 96) or higher for opti- mum engine performance

1ZZ−FE engine 2ZZ−GE engine

1794 (109.5) 1796 (109.6)

Fuel tank capacity, L (gal., Imp. gal.):

55 (14.5, 12.1)

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Service specifications ENGINE Valve clearance (engine cold), mm (in.):

1ZZ−FE engine

Intake Exhaust

0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014)

2ZZ−GE engine (on a roller side)

Intake Exhaust

0.08—0.18 (0.003—0.007) 0.22—0.32 (0.009—0.013)

Spark plug type: 1ZZ−FE engine

DENSO NGK

SK16R11
IFR5A11

2ZZ−GE engine

DENSO NGK

SK20R11
IFR6A11

Spark plug gap, mm (in.):

1.1 (0.043)

ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.): 1ZZ−FE engine

With filter Without filter 2ZZ−GE engine

With filter Without filter

3.7 (3.9, 3.3) 3.5 (3.7, 3.1)

4.4 (4.8, 4.0) 4.2 (4.6, 3.8)

is used

“Toyota Genuine Motor Oil” in your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent to grade and viscosity. Oil grade:

following

satisfy

the

API grade SL “Energy−Conserving” or ILSAC multigrade engine oil

Recommended oil viscosity:

SAE 5W−30

Outside temperature

Please contact your Toyota dealer for fur- ther details.

COOLING SYSTEM Total capacity, L (qt., Imp. qt.):

1ZZ−FE engine

Manual transaxle Automatic transaxle

2ZZ−GE engine

Manual transaxle Automatic transaxle

Coolant type:

5.7 (6.0, 5.0) 5.6 (5.9, 4.9)

5.9 (6.2, 5.2) 5.8 (6.1, 5.1)

“Toyota Super Long Life Coolant” is used in your Toyota vehicle at factory fill. In order to avoid technical problems, only use “Toyota Super Long Life Coolant” or similar high quality ethylene glycol based non−silicate, non−amine, non−nitrite, and non−borate coolant with long−life hybrid organic acid technology. (Coolant with long−life hybrid organic acid technology is a combination of low phosphates and organic acids.) Do not use plain water alone. Please contact your Toyota dealer for further details.

263

2005 CELICA from Sep. ’04 Prod. (OM20888U)

BATTERY Open voltage∗ at 20_C (68_F):

12.6—12.8 V 12.2—12.4 V 11.8—12.0 V

Fully charged Half charged Discharged

∗: Voltage that is checked 20 minutes af- ter the key is removed with all the lights turned off Charging rates:

5 A max.

CLUTCH Pedal free play, mm (in.):

5—15 (0.2—0.6)

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

MANUAL TRANSAXLE Oil capacity, L (qt., Imp. qt.):

1ZZ−FE engine 2ZZ−GE engine

Oil type:

1.9 (2.0, 1.7) 2.3 (2.4, 2.0)

Gear oil API GL−4 or GL−5

Recommended oil viscosity:

SAE 75W−90

264

’05MY CELICA U (L/O 0409)

AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.): 1ZZ−FE engine

Up to 2.9 (3.1, 2.6)

2ZZ−GE engine

Up to 3.5 (3.7, 3.1)

Fluid type:

Toyota Genuine ATF Type T−IV

in

listed

Change automatic transmission fluid only as necessary. Generally, it is necessary to change auto- matic transmission fluid only if your ve- hicle is driven under one of the Special Operating Conditions your “Scheduled Maintenance Guide” or “Own- er’s Manual Supplement”. When changing the automatic transmission fluid, use only “Toyota Genuine ATF Type T−IV” (ATF JWS3309 or NWS6500) to aid in assuring optimum transaxle performance. Notice: Using automatic transmission fluid other than “Toyota Genuine ATF Type T−IV” may cause deterioration in shift quality, locking up of your trans- mission accompanied by vibration, and ultimately damage the automatic trans- mission of your vehicle. Please contact your Toyota dealer for fur- ther details.

BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.):

85 (3.4)

Pedal free play, mm (in.):

1—6 (0.04—0.24)

Pad wear limit, mm (in.):

1.0 (0.04)

Lining wear limit, mm (in.):

1.0 (0.04)

Parking brake adjustment when pulled with the force of 196 N (20 kgf, 44 lbf):

7—8 clicks

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

STEERING Wheel free play:

Less than 30 mm (1.2 in.)

Power steering fluid type:

Automatic transmission fluid DEXRONrII or III

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Tires Tire size and cold tire inflation pressure: Standard tire

Model

Tire size

Tire inflation pressure

kPa (kgf/cm2 or bar, psi) Rear

Front

1ZZ−FE engine

2ZZ−GE engine

Compact spare tire

195/60R15 88H P195/60R15 87H 205/55R15 87V P205/55R15 87V 205/50R16 87V

210 (2.1, 29) 210 (2.1, 29) 220 (2.2, 32) 220 (2.2, 32) 220 (2.2, 32)

210 (2.1, 29) 210 (2.1, 29) 220 (2.2, 32) 220 (2.2, 32) 220 (2.2, 32)

Tire size

T125/70D16 96M

Tire inflation pressure

kPa (kgf/cm2 or bar, psi)

420 (4.2, 60)

Wheel nut torque, N·m (kgf·m, ft·Ibf):

103 (10.5, 76)

Wheel size

15 6 1/2JJ 15 6 1/2JJ 15 6 1/2JJ 15 6 1/2JJ 16 6 1/2JJ

Wheel size

16 4T

NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see “Checking tire inflation pres-

sure” through “Aluminum wheel precautions” in Section 7−2.

265

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Fuses

Engine compartment

Instrument panel

Fuses (type A) 1. AUTO ANTENNA 15 A: Power antenna 2. HEAD LH UPR 10 A: No circuit 3. HEAD RH UPR 20 A: No circuit 4. HEAD LVL DRL NO.1 7.5 A: Daytime light system, headlight beam

running level control system

8. SPARE 30 A: Spare fuse 9. HORN 10 A: Horn 10. ALT−S 7.5 A: Charging system 11. SPARE 15 A: Spare fuse 12. EFI NO.1 10 A: Multiport fuel injection injec-

system/sequential multiport tion system

fuel

5. HEAD RH LWR 15 A: Right−hand

13. DCC 25 A: “RADIO”, “DOME”, “MPX−

headlight (low beam)

B” and “ECU−B” fuses

Engine compartment

266

6. HEAD LH LWR 15 A: Left−hand head-

light (low beam)

7. ABS NO.2 25 A: Anti−lock brake sys-

tem

14. SPARE 10 A: Spare fuse 15. EFI NO.2 10 A: Multiport fuel injection injec-

system/sequential multiport tion system, emission control system

fuel

2005 CELICA from Sep. ’04 Prod. (OM20888U)

16. EFI 20 A: Multiport fuel injection sys- tem/sequential multiport injection system, “EFI NO.1” and “EFI NO.2” fuses

fuel

17. ST 7.5 A: Starting system, multiport injection system/sequential multi-

fuel port fuel injection system

18. AM2 7.5 A: Starting system 19. IG2 15 A: Starting system, multiport injection system/sequential multi-

fuel port fuel injection system

20. HAZ 10 A: Emergency flashers 21. ETCS 10 A: Electronic throttle control

system

22. HEAD RH UPR 10 A: Right−hand

headlight (high beam)

23. HEAD LH UPR 10 A: Left−hand head- light (high beam), daytime running light system

24. S/ROOF 15 A: Electric moon roof 25. FL P/W 20 A: Power windows 26. STOP 10 A: Stop

lights, anti−lock brake system, high mounted stoplight, multiport fuel injection system/sequen- tial multiport fuel injection system, elec- tronically controlled automatic transmis- sion system, cruise control system

’05MY CELICA U (L/O 0409)

27. SRS−IG 7.5 A: SRS airbag system 28. WASHER 15 A: Windshield washer,

rear window washer

Fuses (type B) 42. SPARE 7.5 A: Spare fuse 43. a. MPX−B 7.5 A: Wireless remote con-

29. RADIO 15 A: Audio system 30. TURN 7.5 A: Turn signal lights 31. HTR 10 A: Air conditioning system 32. TAIL 10 A: Tail lights, instrument panel front side

license plate lights,

lights, maker lights

33. CIG 15 A: Cigarette lighter 34. AM1 25 A: Starting system,

“SRS−IG”,

“CIG”, “ECU ACC”, “WASHER”, “WIPER”, “BK/UP LP”, “TENS RDC”, “DEF RLY”, “BODY ECU−IG”, “TURN”, “HTR”, “WARNING”, “FAN RLY”, “ABS− IG” and “ECU−IG” fuses

35. DOOR 20 A: Power door lock system 36. FR FOG 15 A: Front fog lights 37. OBD 7.5 A: On−board diagnosis sys-

tem

38. WIPER 25 A: Windshield wipers 39. MIR HTR 10 A: No circuit 40. RR WIPER 15 A: Rear window wiper 41. FR P/W 20 A: Power windows

trol system

b. RR FOG 7.5 A: No circuit c. DOME 7.5 A: Clock, interior light d. ECU−B 7.5 A: Air conditioning sys-

tem, gauges and meters

44. a. WARNING 5 A: Charging system,

gauges and meters

b. ECU−IG 5 A: Cruise control system c. ABS−IG 5 A: Anti−lock brake sys-

tem

d. FAN RLY 5 A: Electric cooling fan

45. a. PANEL1 7.5 A: Glove box light, in-

strument panel lights

b. PANEL2 7.5 A: Front fog lights, in- instrument

lights,

strument panel cluster lights

c. ECU−ACC 7.5 A: Clock, audio sys- tem, power rear view mirror con- trols, power antenna

267

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

46. a. BK/UP LP 5 A: Back−up lights

b. DEF RLY 5 A: Power windows, rear

window defogger

c. BODY ECU−IG 5 A: Multiplex com-

munication system

d. TENS RDC 5 A: Electronically con- trolled automatic transmission sys- tem, shift lock control system, elec- tric moon roof, power antenna

Fuses (type C) 47. HTR 50 A: Air conditioning system 48. RDI 30 A: Electric cooling fan 49. ABS NO.1 50 A: Anti−lock brake sys-

tem

50. CDS 30 A: Electric cooling fan 51. MAIN 40 A: Starting system, daytime

running light system, “ST” fuse

52. A−PMP 50 A: Emission control system 53. H−LP CLN 50 A: No circuit 54. DEF 30 A: Rear window defogger Fuses (type D) 55. ALT 120 A: Cooling system, electric cooling fan, starting system, rear win- dow defogger, tail lights, “ABS NO.1”, “ABS NO.2”, “FL P/W”, “S/ ROOF”, “MIR HTR”, “FR FOG” and “AM1” fuses

“FR P/W”, “STOP”,

“DOOR”,

“OBD”,

“HTR”,

268

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

SECTION 9

REPORTING SAFETY DEFECTS FOR U.S. OWNERS Reporting safety defects for U.S. owners Reporting safety defects for U.S. owners

. . . . . . . . . . . . . . . . . . . . . .

270

269

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line.

Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331).

If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.

campaign.

270

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Foreword

Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle very well and is interested in your complete satisfaction. Your Toyota dealer will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number:

D U.S. OWNERS: D CANADIAN OWNERS: Toyota Canada Customer Interaction Centre

Toyota Customer Assistance Center

Toll−free: 1−800−331−4331
Toll−free: 1−888−TOYOTA−8 (1−888−869−6828)

Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.

© 2004 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

U −9

Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance D Complete index Gas station information Fuel type:

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

83
186
189
190
191
202
148
174
217
NO TAG

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

1ZZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher 2ZZ−GE engine: Premium UNLEADED gasoline, Octane Rating 91
(Research Octane Number 96) or higher See page 148 for detailed information.

Fuel tank capacity:

55 L (14.5 gal., 12.1 lmp. gal.)

Engine oil:

API grade SL “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 231 for detailed information.

Tire information: See pages 235 through 244. Tire inflation pressure: See page 265.

Publication No. OM20888U Part No. 01999-20888
Printed in Japan 01−0409−00 C

( U)

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Important information about this manual

Safety and vehicle damage warnings

Safety symbol

Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:

CAUTION

This is a warning against anything which may cause is ignored. You are injury to people if the warning informed about what you must or must not do in order to reduce the risk of injury to yourself and others.

NOTICE

This is a warning against anything which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.

the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.

ii

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Important information about your Toyota

Occupant restraint systems

Toyota encourages you and your family to take the time to read Section 1−3 of this Owner’s Manual carefully. In terms of helping you understand how you can receive the maximum benefit of the occupant restraint systems this vehicle provides, Section 1−3 of this Owner’s Manual is the most important Section for you and your family to read. Section 1−3 describes the function and operation concern- ing seats, seat belts, SRS airbags and child restraint sys- tems of this vehicle and some potential hazards you should be aware of. These systems work together along with the overall structure of this vehicle in order to provide occupant restraint in the event of a crash. The effect of each system is enhanced when it is used properly and together with other systems. No single occupant restraint system can, by itself, provide you or your family with the equal level of restraint which these systems can provide when used together. That is why it is important for you and your family to understand the purpose and proper use of each of these systems and how they relate to each other.

The purpose of all occupant restraint systems is to help reduce the possibility of death or serious injury in the event of a collision. None of these systems, either individ- ually or together, can ensure that there is no injury in the event of collision. However, the more you know about these systems and how to use them properly, the greater your chances become of surviving an accident without death or serious injury.

Seat belts provide the primary restraint to all occupants of the vehicle, and every occupant of the vehicle should wear seat belts properly at all times. Children should always be secured in child restraint systems that are appropriate for their age and size. SRS (Supplemental Restraint System) airbags are, as their names imply, designed to work with, and be supplemental to, seat belts and are not substitutes for them. SRS airbags can be very effective in reducing the risk of head and chest injuries by preventing contact of the head and chest with interior portions of the vehicle.

iii

2005 CELICA from Sep. ’04 Prod. (OM20888U)

In order to be effective, the SRS airbags must deploy with tremendous speed. The rapid deployment of the SRS air- bags makes the SRS airbags themselves potential sources of serious injury if an occupant is too close to an airbag, or if an object or some part of his or her body has been placed between the occupant and the airbag at the time of deployment. This is just one example of how the instruc- tions in Section 1−3 of this Owner’s Manual will help en- sure proper use of the occupant restraint systems, and increase the safety they can provide to you and your fami- ly in the event of an accident.

Toyota recommends you to read the provisions in Section 1−3 carefully and refer to them as needed during your time of ownership of this vehicle.

’05MY CELICA U (L/O 0409)

New vehicle warranty

Your new vehicle is covered by the following Toyota limited warranties:

D New vehicle warranty D Emission control systems warranty D Others further

information, please refer

Information Booklet” or

For Warranty Supplement”.

to the “Owner’s “Owner’s Manual

Your responsibility for

maintenance

It is owner’s responsibility to make sure that the specified maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance informa- tion, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

iv

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Important health and safety

information about your Toyota

Accessories, spare parts and modification of your Toyota

CAUTION

D WARNING: Engine exhaust, some of its constitu- ents, and a wide variety of automobile compo- nents contain or emit chemicals known to the State of California to cause cancer and birth de- fects and other reproductive harm. In addition, oils, fuels and fluids contained in vehicles as well as waste produced by component wear con- tain or emit chemicals known to the State of California to cause cancer and birth defects or

other reproductive harm.

D Battery posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling. Used engine oil contains chemicals that have caused cancer in laboratory animals. Always protect your skin by washing

thoroughly with soap and water.

A wide variety of non−genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible either for their performance, repair or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota ve- hicle.

This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty.

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Spark ignition system of your

Tires and loading on your

Toyota

Toyota

The spark ignition system in your Toyota meets all require- ments of the Canadian Interference−Causing Equipment Standard.

Installation of a mobile two−way radio system

As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multi- port fuel injection system/sequential multiport fuel injection system, electronic throttle control system, cruise control system, anti−lock brake system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary measures or special instructions regarding installation.

Underinflated or overinflated tire pressure and the excess load may result in the deterioration of steering ability and braking ability, leading to an accident. Check the tire inflation pressure periodi- cally and be sure to keep the load limits given in this Owner’s Manual. For details about tire inflation pressure and load limits, see “Checking tire infla- tion pressure” in Section 7−2 and “Vehicle load limits” in Section 2.

vi

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Scrapping of your Toyota

If

The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by a qualified service shop or by your Toyota dealer before you dispose of your vehicle.

the vehicle

vii

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

viii

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.

The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.

The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor.

The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.

Periodic maintenance and tune−up

Periodic maintenance and tune−up helps to pre- vent small problems from growing into larger ones lat- er on. The repair manual outlines exactly what main- tenance is required and clearly explains how to do the work yourself step−by−step.

Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.

Where to obtain the

Repair Manual

The repair manual for CELICA, may be pur- chased from any Toyota dealer or the Material Distribution Center. To purchase the repair manual, please contact your Toyota dealer or call the Material Distribution Center toll−free at 1−800−622−2033.

2005 CELICA from Sep. ’04 Prod. (OM20888U)

’05MY CELICA U (L/O 0409)

WE REALLY CARE ABOUT YOU Ċ PLEASE BUCKLE UP

Toyota has made a special effort to encourage use of seat belts.

Toyota belts are:

D Comfortable D Easy to use D Convenient

We encourage you to use your belts every time you drive.

2005 CELICA from Sep. ’04 Prod. (OM20888U)