2007 Toyota Camry HV Owners Manual

367

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

SECTION 7− 3

DO−IT−YOURSELF MAINTENANCE Electrical components Checking 12 volt battery condition 12 volt battery recharging precautions Checking and replacing fuses Checking the fusible link Adding washer fluid Replacing light bulbs

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

369
370
371
372
373
373

368

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

Checking 12 volt battery condition— —12 volt battery location

is

in

located

A 12 volt battery the right−hand side of the trunk. Remove the cover to access the battery. The battery with a flammable hydrogen gas exhaust valve is specially desig- nated for your vehicle. When replacing the battery, contact your Toyota dealer.

’07Camry hybrid_U (L/O 0610)

—Precautions

CAUTION

BATTERY PRECAUTIONS The battery produces flammable and explosive hydrogen gas. D Do not cause a spark from the bat-

tery with tools.

D Do not smoke or light a match near

the battery.

D When replacing

the battery, only install a battery designated for your hybrid vehicle. Using a conventional battery may cause hydrogen gas to build up in the vehicle.

The electrolyte contains poisonous and corrosive sulfuric acid. D Avoid contact with eyes, skin or

clothes.

D Never ingest electrolyte. D Wear protective safety glasses when

working near the battery.

D Keep children away from the bat-

tery.

EMERGENCY MEASURES D If electrolyte gets

in your eyes, flush your eyes with clean water immediately immediate medical attention. If possible, con- tinue to apply water with a sponge or cloth while en route to the medi- cal office.

and get

D If electrolyte gets on your skin, thoroughly wash the contact area. If you feel pain or burning, get medi- cal attention immediately.

D If electrolyte gets on your clothes, there is a possibility of its soaking through to your skin, so immediate- ly take off the exposed clothing and follow the procedure above, if nec- essary.

D If you accidentally swallow electro- lyte, drink a large quantity of water or milk. Follow with milk of magne- sia, beaten raw egg or vegetable oil. Then go immediately for emer- gency help.

369

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

NOTICE

z Be sure the hybrid system and all accessories are off before perform- ing maintenance.

z When checking the battery, remove the ground cable from the negative terminal (“−” mark) first and rein- stall it last.

z Be careful not to cause a short cir-

cuit with tools.

z Take care no solution gets into the

battery when washing it.

—Checking the 12 volt battery exterior

Terminals

Hold−down clamp

Ground cable

Check the battery for corroded or loose terminal connections, cracks, or loose hold−down clamp. a. If the battery is corroded, wash it off with a solution of warm water and bak- ing soda. Coat the outside of the termi- nals with grease to prevent further cor- rosion.

b. If the terminal connections are loose, their clamp nuts—but do not

tighten overtighten.

c. Tighten

the hold−down clamp only enough to keep the battery firmly in place. Overtightening may damage the battery case.

370

12 volt battery recharging precautions During recharging, the battery is pro- ducing hydrogen gas. Therefore, before recharging: 1. If recharging with the battery installed on the vehicle, be sure to disconnect the ground cable.

2. Be sure the power switch on the re- charger the charger cables to the battery and when disconnecting them.

is off when connecting

CAUTION

D Always charge the battery in an un- confined area. Do not charge the battery in a garage or closed room where there is not sufficient ventila- tion.

D Only do a slow charge (5 A or less). Charging at a quicker rate is dangerous. The battery may ex- plode, causing personal injuries.

NOTICE

Never recharge the battery while the hybrid system is operating. Also, be sure all accessories are turned off.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Checking and replacing fuses

Good

Blown

Good

Blown

Type A

Type C

Good

Blown

Type B

If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” on page 348 in Sec- tion 7−1 for locations of the fuses. Turn the hybrid system and inoperative component off. Pull the suspected fuse straight out and check it. Determine which fuse may be causing the problem. The lid of the fuse box shows the name of the circuit for each fuse. See page 386 in Section 8 for the functions controlled by each circuit. Type B fuses—When any of the fuses are blown, contact your Toyota dealer.

371

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

Type A fuses can be pulled out by the pull−out tool. The location of the pull−out tool is shown in the illustration. If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good. If the fuse has blown, push a new fuse into the clip. Only install a fuse with the amperage rat- ing designated on the fuse box lid. If you do not have a spare fuse, in an emergency you can pull out the “RADIO NO.1” or “PWR OUTLET” fuse, which may be dispensable for normal driving, and use it if its amperage rating is the same. If you cannot use one of the same amper- age, use one that is lower, but as close to the rating as possible. If the amperage is fuse might blow out again but this does not indicate anything wrong. Be sure to get the correct fuse as soon as possible and return the substitute to its original clip. It is a good idea to purchase a set of spare fuses and keep them in your ve- hicle for emergencies.

that specified,

lower

than

the

372

’07Camry hybrid_U (L/O 0610)

Checking the fusible link

the new

If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your Toyota dealer correct it as soon as possible.

CAUTION

Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.

If the headlights or other electrical components do not work and the fuses are O.K., check the fusible link fitted on the “+” terminal of the 12 volt bat- tery. If the link is melted, it must be replaced. If there is an overload in the circuits, the fusible links are designed to melt before the entire wiring harness is damaged. The battery is located in the right−hand side of the trunk. See “—12 volt battery location” on page 369 in this Section.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Adding washer fluid If the washer does not work or the message “LOW WASHER FLUID” ap- pears on the multi−information display, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. However, in cold areas where tempera- tures range below the freezing point, use washer fluid containing antifreeze. This product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer’s directions for how much to mix with water.

NOTICE

Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.

following

illustrations show how

Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the hybrid system and light switch are off. Use bulbs with the wattage ratings given in the table. The stop/tail lights and high mounted stop- light consist of a number of LEDs. If any of the LEDs burn out, take your vehicle to your Toyota dealer to have the light replaced. If two or more LEDs in a stop light burn out, your vehicle may not conform to local laws (SAE).

CAUTION

D To prevent burning yourself, do not replace the light bulbs while they are hot.

D Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.

NOTICE

Only use a bulb of the listed type.

the

The inside of the lens of exterior lights such as headlights may temporarily fog up when the lens becomes wet in the rain or in a car wash. This is not a problem because the is caused by fogging temperature difference between the outside and the windshield fogs up in the rain. However, if there large drop of water on the inside of the lens, or if there is water pooled light, contact your Toyota dealer.

inside of

inside

lens,

is a

just

like

the

the

373

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

W Type

Bulb No.

9005

—

—

60

55

3457NAK 30/8

—

—

921

—

—

168

—

—

—

21

16

1.2

3.8

Light bulbs

Headlights (high) Headlights (low)

Front side marker lights Front turn signal/parking lights Rear turn signal lights License plate lights Back−up lights

Personal lights

Interior light

Door courtesy lights Vanity lights

Glove box light

Trunk light

374

’07Camry hybrid_U (L/O 0610)

A: HB3 halogen bulbs B: H11 halogen bulbs C: Wedge base bulbs (clear) D: Wedge base bulbs (amber) E: Double end bulbs

—Front turn signal/parking, side marker, tail and back−up lights, and high mounted stoplight If turn signal/parking, side marker, tail or back−up lights, or high mounted stoplight burns out, contact your Toyota dealer.

front

the

NOTICE

Do not try to replace the front turn signal/parking, side marker, tail, back− up light and high mounted stoplight bulbs by yourself. You may damage the vehicle.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

—Headlights

Low beam (outside)

High beam (inside)

1. Open the hood. Turn the bulb base counterclockwise to the front of the vehicle as shown.

The above illustration shows the left−hand headlight.

2. Unplug the connector while depress-

ing the lock release.

If the connector is tight, wiggle it.

3. Plug in a new bulb into the connec- tor and install it into the mounting hole. is not necessary after replacing Aiming the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

375

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

—Rear turn signal lights

376

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

377

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

SECTION 8

SPECIFICATIONS Specifications Dimensions and weights Engine Fuel Traction motor Hybrid battery Service specifications Tires Fuses

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

380
380
381
381
381
382
385
386

379

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Dimensions and weights

Overall length

Overall width Overall height∗

Wheelbase

Front tread

Rear tread

Vehicle capacity weight (occupants + luggage) ∗: Unladen vehicle

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

kg (lb.)

4805 (189.2)

1820

(71.7)

1470

(57.9)

2775 (109.3)

1575

(62.0)

1565

(61.6)

410

(900)

Engine Model:

2AZ−FXE

Type:

4 cylinder in line, 4 cycle, gasoline

Bore and stroke, mm (in.):

88.5 96.0 (3.48 3.78)

Displacement, cm3 (cu. in.):

2362 (144.1)

380

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Fuel Fuel type:

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher

Fuel tank capacity, L (gal., Imp. gal.):

65 (17.2, 14.3)

Traction motor Type:

Hybrid battery Type:

Permanent magnet synchronous motor

Nickel−Metal hydride battery

Maximum output:

105 kW

Maximum torque:

270 N·m (27.5 kgf·m, 199 ft·lbf)

Voltage:

7.2 V/module

Capacity: 6.5 Ah Quantity:

34 modules

Overall voltage:

244.8 V

381

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Service specifications ENGINE Valve clearance (engine cold), mm (in.):

Intake Exhaust

0.19—0.29 (0.007—0.011) 0.38—0.48 (0.015—0.019)

Spark plug type:

DENSO NGK

SK20R11
IFR6A11
Spark plug gap, mm(in.):

1.1 (0.043)

NOTICE

Use only above spark plugs. Do not adjust gaps for engine performance or smooth driveability.

ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):

With filter Without filter

4.3 (4.5, 3.8) 4.1 (4.3, 3.6) “Toyota Genuine Motor Oil” in your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent to grade and viscosity. Oil grade:

following

is used

satisfy

the

ILSAC multigrade engine oil

Recommended oil viscosity:

SAE 5W−20 or 0W−20

Outside temperature

Please contact your Toyota dealer for fur- ther details.

382

COOLING SYSTEM Total capacity, L (qt., Imp. qt.):

Engine

6.2 (6.6, 5.5)

Inverter, traction motor and motor gener- ator

2.9 (3.1, 2.6)

Coolant type:

“Toyota Super Long Life Coolant” is used in your Toyota vehicle at factory fill. In order to avoid technical problems, only use “Toyota Super Long Life Coolant” or similar high quality ethylene glycol based non−silicate, non−amine, non−nitrite, and non−borate coolant with long−life hybrid organic acid technology. (Coolant with long−life hybrid organic acid technology is a combination of low phosphates and organic acids.) Do not use plain water alone. Please contact your Toyota dealer for further details.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

12 VOLT BATTERY Open voltage∗ at 20_C (68_F):

12.6—12.8 V 12.2—12.4 V 11.8—12.0 V

Fully charged Half charged Discharged

∗: Voltage that is checked 20 minutes af- ter the key is removed with all the lights turned off Charging rates:

5 A max.

CAUTION

replacing

When the battery, only install a battery designated for your hybrid vehicle. Using a conventional battery may cause hydrogen gas to build up in the vehicle.

’07Camry hybrid_U (L/O 0610)

TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.):

3.8 (4.0, 3.3)

Fluid type:

Toyota Genuine ATF WS

it

is necessary

Change the transmission fluid only as nec- essary. Generally, to change transmission fluid only if your vehicle is driven under one of the Special Operating Conditions “Scheduled Maintenance Guide” or “Owner’s Manual the Supplement”. When use only transmission fluid, “Toyota (ATF JWS3324 or Genuine ATF WS” NWS9638) in assuring optimum transaxle performance.

changing

to aid

listed

your

in

Notice: Using transmission fluid other than “Toyota Genuine ATF WS” may cause deterioration in shift quality, locking up of your transmission accom- panied by vibration, and ultimately dam- age the transmission of your vehicle. Please contact your Toyota dealer for fur- ther details.

383

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the hybrid system operating, mm (in.):

80 (3.1)

Pedal free play, mm (in.):

1—2 (0.04—0.08)

Pad wear limit, mm (in.):

1.0 (0.04)

Parking brake

Parking brake adjustment when de- pressed with the force of 300 N (31 kgf, 67 lbf):

7—10 clicks

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

STEERING Wheel free play:

Less than 30 mm (1.2 in.)

384

’07Camry hybrid_U (L/O 0610)

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Tires Tire size and cold tire inflation pressure: Front and rear

kPa (kgf/cm2 or bar, psi)

Tire size

Front

P215/60R16 94V

220 (2.2, 32)

Rear

220 (2.2, 32)

Wheel size

16 6 1/2 J

When driving under the above vehicle conditions at sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire inflation pressure molded on the tire sidewall. Spare

kPa (kgf/cm2 or bar, psi)

Tire size

Front

T155/70D17 110M

420 (4.2, 60)

Rear

420 (4.2, 60)

Wheel size 17 4T

Wheel nut torque, N·m (kgf·m, ft·lbf):

103 (10.5, 76)

NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see “Checking tire inflation pres-

sure” through “Aluminum wheel precautions”, pages 359 through 367, in Section 7−2.

385

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

Fuses

386

’07Camry hybrid_U (L/O 0610)

ENGINE COMPARTMENT 1. AM2 7.5 A: “POWER” switch 2. ABS MAIN No.2 10 A: Electronically

controlled brake system

3. ABS MAIN No.1 10 A: Electronically

controlled brake system

4. ABS MAIN No.3 10 A: Electronically

controlled brake system

5. BATT FAN 10 A: Hybrid battery fan 6. ETCS 10 A: Electronic throttle control

system

7. HAZ 15 A: Turn signal lights 8. IG2 20 A: Multiport fuel injection sys- injection “GAUGE

tem/sequential multiport system, system, NO.2”, “IGN” and “INJ” fuses

starting

fuel

9. STR LOCK 20 A: Steering lock system 10. DOME 10 A: Gages and meters, vanity lights, “POWER” switch light, door courtesy lights, interior light, personal key system

lights,

clock,

smart

trunk

light,

11. ECU−B NO.1 10 A: Front passenger occupant classification system, main body ECU

12. RADIO NO.1 15 A: Audio system, nav-

igation system

13. DOOR NO.1 25 A: Main body ECU,

power door lock

14. IGCT 30 A: Hybrid system ECU, “PWR”, “IGCT No.2” and “INV W/P” fuses

15. AMP 25 A: Audio system 16. EFI MAIN 30 A: Multiport fuel injection system/sequential multiport injec- tion system, electronic throttle control system and “EFI NO.3” fuses

fuel

17. EFI NO.3 10 A: Fuel tank system, mul- injection system/sequential

tiport multiport fuel injection system

fuel

18. IGCT NO.2 10 A: Hybrid system ECU,

motor generator ECU

19. INV W/P 15 A: Hybrid system ECU, traction battery, DC/DC converter, mul- tiport injection system/sequential multiport fuel injection system

fuel

20. S−HORN 7.5 A: No circuit 21. A/F 20 A: No circuit 22. MPX−B 10 A: Gauges and meters 23. EFI NO.1 10 A: Smart key system 24. HORN 10 A: Horns 25. H−LP(RL) 15 A: Right−hand headlight

(low beam)

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

26. H−LP(LL) 15 A: Left−hand headlight

(low beam)

27. H−LP(RH) 15 A: Right−hand headlight

(high beam)

28. H−LP(LH) 15 A: Left−hand headlight

(high beam)

29. HTR 50 A: Air conditioning system 30. HTR SUB2 50 A: PTC heater 31. HTR SUB1 50 A: PTC heater 32. RR DEF 50 A: Rear window defogger,

“MIR HTR” fuse

33. CDS FAN 40 A: Electric cooling fans 34. RDI FAN 40 A: Electric cooling fans 35. DC/DC 120 A: “ABS MTR2”, “EPS”, “AM2”, DOOR NO.1”, “ABS MTR”, “ETCS”, “ABS MAIN1”, “ABS MAIN2”, “STR LOCK”, “ABS MAIN3”, “BTT FAN”, “EFI MAIN”, “EFI NO.1” and “IGCT” fuses

“AMP”,

“HAZ”,

“IG2”,

36. EPS 80 A: Electric power steering sys-

tem

37. ABS MTR2 40 A: Electronically con-

trolled brake system

38. ABS MTR1 50 A: Electronically con-

trolled brake system

’07Camry hybrid_U (L/O 0610)

INSTRUMENT PANEL 1. RR DOOR RH 25 A: Rear right power

window

2. RR DOOR LH 25 A: Rear left power

window

3. FUEL OPN 7.5 A: Fuel

fillter door

opening system

4. FR FOG 15 A: No circuit 5. OBD 7.5 A: On−board diagnosis sys-

tem

6. ECU−B NO.2 7.5 A: No circuit

7. STOP 10 A: Stop lights, high mounted stoplight, shift lock control system, multiport fuel injection system/sequen- tial multiport fuel injection system, main body ECU, electronically controlled brake system, electronic throttle control system

8. TI&TE 30 A: No circuit 9. AM1 7.5 A: Starting system, multiport injection system/sequential multi-

fuel port fuel injection system

10. A/C 7.5 A: Air conditioning system 11. PWR 25 A: Power windows 12. DOOR NO.2 25 A: Main body ECU 13. S/ROOF 30 A: Electric moon roof 14. TAIL 15 A: Front side marker lights, tail lights, rear side marker lights, li- cense plate lights

15. PANEL 7.5 A: Navigation system, seat heaters, emergency flashers, air condi- tioning system, audio system, glove box light, instrument panel lights, steer- ing switches, clock

16. ECU IG NO.1 10 A: Main body ECU, push start system, electric moon roof, auto anti−glare inside rear view mirror, tire pressure warning system, naviga- tion system

387

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

17. ECU

IG NO.2 7.5 A: Electronically controlled brake system, electric power steering system, shift lock control sys- tem

27. ECU−ACC 7.5 A: Clock, main body ECU, shift lock control system, outside rear view mirrors, smart key system, push start system

18. A/C NO.2 10 A: Air conditioning sys-

tem, rear window defogger

19. WASH 10 A: Windshield wipers and

washer

20. S−HTR 20 A: Seat heaters 21. GAUGE NO.1 10 A: Emergency flash-

ers, back−up lights

22. WIP 25 A: Windshield wipers and

washer

28. CIG 20 A: No circuit 29. PWR OUTLET 20 A: Power outlet 30. RADIO NO.2 7.5 A: Audio system,

navigation system

31. MIR HTR 10 A: Outside rear view mir-

ror defoggers

32. 30 A: Power windows 33. 30 A: Power seats

23. H−LP LVL 7.5 A: No circuit 24. INJ 15 A: Multiport fuel injection sys- injection

tem/sequential multiport system

fuel

fuel

25. IGN 10 A: Multiport fuel injection sys- tem/sequential multiport injection system, SRS airbag system, steering lock system, front passenger occupant classification system, smart key sys- tem, electronic throttle control system 26. GAUGE NO.2 7.5 A: Gages and me-

ters, clock

388

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

SECTION 9

REPORTING SAFETY DEFECTS FOR U.S. OWNERS Reporting safety defects for U.S. owners Reporting safety defects for U.S. owners

. . . . . . . . . . . . . . . . . . . . . .

390

389

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Safety Hotline

the To contact NHTSA, you may call Vehicle at toll−free 1−888−327−4236 (TTY: 1−800−424−9153); go to http://www.safercar.gov; or write to: Administrator, NHTSA, 400 Seventh Street, SW., Washington, DC 20590. You can also information about motor obtain other vehicle from http://www.safercar.gov.

safety

Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.

campaign.

390

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Foreword

Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle very well and is interested in your complete satisfaction. Your Toyota dealer will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, please call the following number: U.S. OWNERS:

D When traveling in the U.S. mainland or Canada:

Toyota Customer Experience Center

Toll−free:1−800−331−4331

D Hawaii:

Servco Automotive Customer Services

Toll−free:1−888−272−5515

CANADIAN OWNERS:

D When traveling in Canada or the U.S. mainland:

Toyota Canada Customer Interaction Centre

Toll−free:1−888−TOYOTA−8 or 1−888−869−6828
Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle. Please access our websites for further information. D The U.S. mainland D Hawaii D Canada

www.toyota.com www.toyotahawaii.com www.toyota.ca

© 2006 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

AU 4

Quick index D If a service reminder indicator or warning buzzer comes on D If a message appears D If your vehicle will not start D If your hybrid system stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D If a road accident occurs D Tips for driving during break−in period D How to start the hybrid system D General maintenance D Complete index Gas station information Fuel type:

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

150
140
313
317
317
318
327
13
275
301
342
NO TAG

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher. See page 275 for detailed information.

Fuel tank capacity:

65 L (17.2 gal., 14.3 Imp. gal.)

Engine oil:

ILSAC multigrade engine oil is recommended. See page 356 for detailed information.

Tire information: See pages 359 through 367. Tire inflation pressure: See page 385.

Publication No. OM33749U Part No. 01999-33749
Printed in Japan 01−0612−00

Hybrid ( U)

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Important information about this manual

Safety and vehicle damage warnings

Safety symbol

Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:

CAUTION

This is a warning against anything which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to reduce the risk of injury to yourself and others.

NOTICE

This is a warning against anything which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.

the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.

ii

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Important information about your Toyota

Hybrid system on your vehicle

Occupant restraint systems

Your vehicle is a hybrid vehicle. It has characteristics dif- ferent from other conventional vehicles. You must under- stand the characteristics of your vehicle very well and han- dle it carefully. Read this manual and follow the instruc- tions. Section 1−1 explains the characteristics of the hy- brid system.

Toyota encourages you and your family to take the time to read Section 1−3 of this Owner’s Manual carefully. In terms of helping you understand how you can receive the maximum benefit of the occupant restraint systems this vehicle provides, Section 1−3 of this Owner’s Manual is the most important Section for you and your family to read. Section 1−3 describes the function and operation concern- ing seats, seat belts, SRS airbags and child restraint sys- tems of this vehicle and some potential hazards you should be aware of. These systems work together along with the overall structure of this vehicle in order to provide occupant restraint in the event of a crash. The effect of each system is enhanced when it is used properly and together with other systems. No single occupant restraint system can, by itself, provide you or your family with the equal level of restraint which these systems can provide when used together. That is why it is important for you and your family to understand the purpose and proper use of each of these systems and how they relate to each other.

iii

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

The purpose of all occupant restraint systems is to help reduce the possibility of death or serious injury in the event of a collision. None of these systems, either individ- ually or together, can ensure that there is no injury in the event of collision. However, the more you know about these systems and how to use them properly, the greater your chances become of surviving an accident without death or serious injury.

Seat belts provide the primary restraint to all occupants of the vehicle, and every occupant of the vehicle should wear seat belts properly at all times. Children should always be secured in child restraint systems that are appropriate for their age and size. SRS (Supplemental Restraint System) airbags are, as their names imply, designed to work with, and be supplemental to, seat belts and are not substitutes for them. SRS airbags can be very effective in reducing the risk of head, chest and knee injuries by preventing contact of the head, chest and knee with interior portions of the vehicle.

In order to be effective, the SRS airbags must deploy with tremendous speed. The rapid deployment of the SRS air- bags makes the SRS airbags themselves potential sources of death or serious injury if an occupant is too close to an airbag, or if an object or some part of his or her body has been placed between the occupant and the airbag at the time of deployment. This is just one example of how the instructions in Section 1−3 of this Owner’s Manual will help ensure proper use of the occupant restraint systems, and increase the safety they can provide to you and your fami- ly in the event of an accident.

Toyota recommends you to read the provisions in Section 1−3 carefully and refer to them as needed during your time of ownership of this vehicle.

iv

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Event data recorder

Your vehicle has computers that monitor and control cer- tain aspects of your vehicle. These computers assist in driving and maintaining optimal vehicle performance. Be- sides storing data useful for troubleshooting, there is a system to record data in a crash or a near car crash event. This is called an Event Data Recorder (EDR).

The SRS airbag sensor assembly contains the EDR. In a crash or a near car crash event, this device may record some or all of the following information:

D Engine speed D Whether the brake pedal was applied or not D Vehicle speed D To what extent the accelerator pedal was depressed D Position of the transmission selector lever D Whether the driver and front passenger wore the seat

belts or not

D Driver’s seat position D Front passenger’s occupant classification

D SRS airbag deployment data D SRS airbag system diagnostic data

If your vehicle is equipped with a vehicle stability control (VSC) system, its Electronic Control Unit (ECU) may con- tain another EDR. There are a variety of driving situations which include activating the VSC under which the VSC EDR will record certain information. The VSC EDR may record some or all of the following information:

D Behavior of the vehicle D Steering wheel angle D Vehicle speed D To what extent the accelerator pedal was depressed D To what extent the brake pedal was applied D To what extent the ECU controlled the condition of

the 4 wheels

D Vehicle stability control system diagnostic data

The information above is intended to be used for the purpose of improving vehicle safety performance. Unlike general data recorders, the EDR does not record sound data such as conversation between passengers.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

Toyota will not disclose the data recorded in an EDR to a third party except when:

D An agreement from the vehicle’s owner (or the leas-

ing company for a leased vehicle) is obtained

D Officially requested by the police or other authorities D Used as a defense for Toyota in a law suit D Ordered by the court

However, if necessary Toyota will:

D Use the data for research on Toyota vehicle safety

performance

D Disclose the data to a third party for research pur- poses without disclosing details of the vehicle owner, and only when it is deemed necessary

D Disclose summarized data cleared of vehicle identifi- for

to a non−Toyota organization

cation information research purposes

’07Camry hybrid_U (L/O 0610)

New vehicle warranty

Your new vehicle is covered by the following Toyota limited warranties:

D New vehicle warranty D Emission control systems warranty D Others

For further information, please refer to the “Owner’s War- ranty Information Booklet” or “Owner’s Manual Supple- ment”.

Your responsibility for

maintenance

It is the owner’s responsibility to make sure that the speci- fied maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance in- formation, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

vi

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Important health and safety

information about your Toyota

Accessories, spare parts and modification of your Toyota

CAUTION

D WARNING: Engine exhaust, some of its constitu- ents, and a wide variety of automobile compo- nents contain or emit chemicals known to the State of California to cause cancer and birth de- fects and other reproductive harm. In addition, oils, fuels and fluids contained in vehicles as well as waste produced by component wear con- tain or emit chemicals known to the State of California to cause cancer and birth defects or

other reproductive harm.

D Battery∗ posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling. Used engine oil contains chemicals that have caused cancer in laboratory animals. Always protect your skin by washing

thoroughly with soap and water.

∗: The 12 volt battery for the hybrid vehicle

vii

A wide variety of non−genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible for their performance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.

This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Spark ignition system of your

Installation of a mobile two−way

Toyota

radio system

The spark ignition system in your Toyota meets all require- ments of the Canadian Interference−Causing Equipment Standard.

As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as Toyota hybrid system, cruise control system, electronically con- trolled brake system, vehicle dynamics integrated manage- ment, SRS airbag system and seat belt pretensioner sys- tem, be sure for precautionary measures or special instructions regarding installation.

to check with your Toyota dealer

High voltage parts and cables on the hybrid vehicles emit approximately the same amount of electromag- netic waves as the conventional gasoline powered vehicles or home electronic appliances despite of their electromagnetic shieldings. Unwanted noise may occur in the reception of the mobile two−way radio.

viii

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Smart key system

Leak detection pump

Users of any electrical medical devices such as im- planted pacemakers should consult the manufacturer of the device for information about its operation under the influence of radio waves. Radio waves could have unex- pected effects on the operation of such medical devices. For details, see “Keys” on page 22 in Section 1−2.

This pump performs fuel evaporation leakage check. This check is done approximately five hours after the hybrid system is turned off. So you may hear sound coming from underneath the trunk for several minutes. It does not indi- cate a malfunction.

Tires and loading on your

Toyota

Underinflated or overinflated tire pressure and the excess load may result in the deterioration of steering ability and braking ability, leading to an accident. Check the tire inflation pressure periodi- cally and be sure to keep the load limits given in this Owner’s Manual. For details about tire inflation pressure and load limits, see pages 359 and 295.

Hybrid battery

The hybrid battery has a limited service life. Call your Toyota dealer or a qualified service shop for information about recycling or disposal of the battery.

ix

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Scrapping of your Toyota

High voltage cautions

CAUTION

CAUTION

In the event that your vehicle must be disposed of, make sure to contact your Toyota dealer or a quali- fied service shop. If your vehicle is disposed of without the hybrid battery having been removed, there is a danger of serious electric shock if high voltage parts, cables and their connectors are tou- ched. The hybrid batteries must be disposed of by your Toyota dealer or a qualified service shop. If the traction batteries are not disposed of properly, they may cause electric shock that can result a death or serious injury.

If

The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by the qualified service shop or by your Toyota dealer before you dispose of your vehicle.

the vehicle

The vehicle has high voltage DC and AC systems as well as a 12−volt system. DC and AC high voltage is very dangerous and can cause severe burns and electric shock that may result in death or serious injury. D Never touch, disassemble, remove or replace the high voltage parts, cables and their connectors. High voltage parts and cables are indicated in the illustration on page 7. Touching, disassembling, re- moving or replacing those parts and cables can cause severe burns or electric shock that may re- sult in death or serious injury.

D Never try to open the service plug access hole located in the trunk. The service plug is used only when the vehicle is serviced and is subject to high voltage. Touching the service plug can cause severe burns or electric shock that may result in death or serious injury.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

D The hybrid system uses high voltage up to 650 V. The system can be hot while and after starting. Be careful of both the high voltage and the high tem- perature. Obey the caution labels attached to the vehicle.

’07Camry hybrid_U (L/O 0610)

Road accident cautions

CAUTION

D Pull your vehicle off the road, put the transmis- sion in the “P” position, apply the parking brake, turn the hybrid system off and carry the key.

D In order to avoid death or serious injury, do not touch high voltage wiring, connectors or high volt- age parts (inverter unit, hybrid battery and etc.). High voltage parts and cables are indicated in the illustration on page 7.

D If exposed electric wires are protruding inside or outside of your vehicle, an electric shock may oc- cur. Never touch the electric wires.

D If fluid leaks or gets into some parts of the ve- hicle, never touch it because it may be strong al- kaline electrolyte from the hybrid battery. If it con- tacts your skin or eyes, wash it off immediately with a large amount of water or if possible, boric acid solution. Get immediate medical attention in order to help avoid serious injury.

xi

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

D If a fire occurs in the hybrid vehicle, leave the vehicle as soon as possible. Never use a fire ex- tinguisher that is not meant for use on electric fires. Using a small amount of water may be also dangerous.

D If your vehicle needs to be towed, do it with the front wheels raised. If the wheels with the motor generator are on the ground when towing, the mo- tor may continue to generate electricity. This may cause the electricity leakage. Depending on the se- leakage may verity of cause to be towed” on page 327 in Section 4.

fire. See “If your vehicle needs

the damage, electricity

’07Camry hybrid_U (L/O 0610)

Perchlorate Material

Special handling may apply, See www.dtsc.ca.gov/hazardouswaste/perchlorate.

Your vehicle has components that may contain perchlorate. These components may include airbag, seat belt preten- sioners, and wireless remote control batteries.

xii

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.

The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.

The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor. The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.

Hybrid vehicles contain high voltage parts and cables that are extremely dangerous and may cause severe injury or even death if handled improperly. Only technicians who have participated in technical training for the inspection and servicing of high voltage systems are qualified to do maintenance work on components related to the vehicle’s hybrid system. For repair of your hybrid system, visit your Toyota dealer or other qualified technicians.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.

Periodic maintenance and tune−up

Periodic maintenance and tune−up helps to prevent small problems from growing into larger ones later on. The repair manual outlines exactly what maintenance is required and clearly explains how to do the work yourself step−by−step. Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.

Where to obtain the

Repair Manual

The repair manual for CAMRY may be purchased from any Toyota dealer or the Material Distribu- tion Center. To purchase the repair manual, please contact your Toyota dealer or call the Material Dis- tribution Center toll−free at 1−800−622−2033.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)

’07Camry hybrid_U (L/O 0610)

WE REALLY CARE ABOUT YOU Ċ PLEASE BUCKLE UP

Toyota has made a special effort to encourage use of seat belts.

Toyota belts are:

D Comfortable D Easy to use D Convenient

We encourage you to use your belts every time you drive.

2007 CAMRY HV from Oct. ’06 Prod. (OM33749U)