2003 Ford Escape Owners Manual

Download PDF Manual
Oil (Canada) Motorcraft SAE 75W-90 Gear Oil Motorcraft MERCON威 ATF Motorcraft MERCON 威ATF Engine oil Manual transaxle Automatic transaxle2 Power steering fluid Ford Part Number XG-4 or XL-5 Ford Specification ESB-M1C93-B or ESR-M1C159-A PM-1 ESA-M6C25-A and DOT 3 XG-1-C or XG-1-T or XG-1-K VC-7–A ESA-M1C75-B WSS-M97B51-A1 XO-5W20-QSP (US) CXO-5W20–LSP12 (Canada) WSS-M2C153-H with API Certification Mark F32Z-19C547–MA WSS-M2C203-A1 XT-2-QDX MERCON威 XT-2-QDX MERCON威 223 Maintenance and Specifications Item Ford Part Name or equivalent Rear axle (4X4)4 Motorcraft SAE Power Take-off(PTO) (4X4-Manual Transaxle) Power Take-off(PTO)3 (4X4-Automatic Transaxle) Windshield washer fluid 80W-90 Premium Rear Axle Lubricant Motorcraft SAE 80W-90 Premium Rear Axle Lubricant Motorcraft SAE 75W-140 Synthetic Rear Axle Lubricant Motorcraft Premium Windshield Washer Concentrate Ford Part Number XY-80W90-QL Ford Specification WSP-M2C197-A XY-80W90-QL WSP-M2C197-A XY-75W140–QL WSL-M2C192-A ZC-32–A WSB-M8B16–A2 1DO NOT USE Ford Extended Life Engine Coolant F6AZ-19544-AA, meeting Ford specification WSS-M97B44-D (orange in color) Refer to Adding engine coolant, in the Maintenance and Care chapter. 2Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. MERCON威 and MERCON威 V are not interchangeable. DO NOT mix MERCON威 and MERCON威 V. Refer to your scheduled maintenance guide to determine the correct service interval. 3The Power Take-off(PTO) is lubricated for life with synthetic lube. Lubricant levels are not to be checked or changed unless a leak is suspected or repair required. Replace Power Take-off(PTO) lubricant with specified synthetic lubricant anytime the unit is submerged in water. Never engage the 4X4 feature while on dry pavement. 44X4 vehicles exposed for prolonged periods to temperatures less than –40° C (-40° F) should change out the rear axle fluid to Motorcraft SAE 75W-140 Synthetic Rear Axle Lubricant, Ford part number XY-75W140–QL meeting Ford specification WSL-M2C192–A. 224 Maintenance and Specifications ENGINE DATA Engine Cubic inches Required fuel Firing order Spark plug gap Ignition system Compression ratio 2.0L DOHC I4 Zetec engine 121 87 octane 1-3-4-2 1.22-1.32 mm (0.048-0.052 inch) DIS 9.6:1 3.0L DOHC V6 Duratec engine 181 87 octane 1-4-2-5-3-6 1.32-1.42 mm (0.052-0.056 inch) Coil on plug 10.0:1 4 Door mm (in.) 1755 (69.1)/1774 (69.8)* VEHICLE DIMENSIONS Dimensions (1) Vehicle height/ Maximum height* 1551 (61.1)/1530 (60.2) (2) Front track / rear 1780 (70.1) (3)Overall width (body) 2620 (103.1) (4) Wheelbase (5)Overall length 4393 (173.0) * Denotes a 4x4 vehicle with optional 16” tires 225 Maintenance and Specifications 226 Maintenance and Specifications IDENTIFYING YOUR VEHICLE Certification label The National Highway Traffic Safety Administration Regulations require that a Certification label be affixed to a vehicle and prescribe where the Certification label may be located. The Certification label is located on the front door latch pillar on the driver’s side. 227 Maintenance and Specifications Vehicle identification number (VIN) The vehicle identification number is attached to a metal tag and is located on the driver side instrument panel. (Please note that in the graphic XXXX is representative of your vehicle identification number.) XXXXXXXXXXXXXXXXX 1. World manufacturer identifier 2. Brake type and gross vehicle weight rating (GVWR) 3. Vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number Engine number The engine number (the last eight numbers of the vehicle identification number) is stamped on the engine block, transmission and frame. 228 Accessories Accessories FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of genuine Ford accessories are available for your vehicle through your local authorized Ford, Lincoln, Mercury or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle. In addition, each accessory is made from high quality materials and meets or exceeds Ford’s rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Ford accessory found to be defective in factory-supplied materials or workmanship during the warranty period, as well as any component damaged by the defective accessory. The accessory will be warranted for whichever provides you the greatest benefit: • 12 months or 20,000 km (12,000 miles) (whichever occurs first), or • the remainder of your new vehicle limited warranty. This means that genuine Ford accessories purchased along with your new vehicle and installed by the dealer are covered for the full length of your New Vehicle’s Limited Warranty — 3 years or 60,000 km (36,000 miles) (whichever occurs first). Contact your dealer for details and a copy of the warranty. Not all accessories are available for all models. Following is a list of several Ford Genuine Accessory products. Not all accessories are available for all models. To find out what accessories are available for your vehicle, please contact your dealer or visit our online store at: www.fordaccessories.com. Vehicle Security Non-decorative wheel protector locks Remote keyless entry Styled wheel protector locks Vehicle security systems 229 Accessories Comfort and convenience Cabin air filtration Cargo net Cargo organizers Cargo shades Cargo trays Carpeted cargo mat Cellular phone hands free system with voice recognition Engine block heater Engine oil cooler Interior dash trim kit Power point outlet (rear cargo area) Remote start Tire step Travel equipment Auto headlamps with DRL (Daytime Running Lights) Daytime running lights Factory luggage rack adaptors: bike ski/snowboard First aid kit Framed luggage cover Highway safety kit Hitch mounted bike rack Luggage basket/box carrier Luggage basket light bracket Luggage divider Mirror I/S electrochromic compass with and without temperature display Pet guard Rear seat entertainment system (DVD) Removable luggage rack (Track riders) Removable luggage rack adapters: bike, ski/snowboard, canoe and kayak Running boards 230 Running bars Soft luggage cover Trailer hitch (Class II) Trailer hitch bars and balls Trailer hitch receiver cover Trailer hitch wiring adaptor Trailgate table (hitch installed) and adaptor kit Wheels Protection and appearance equipment Air bag anti-theft locks All weather floor mats Bumper guards Car/truck covers Cargo liners, interior (soft and rigid) Carpet floor mats Door edge guards Front end covers (full and sport) Grill guard Hood deflectors Locking gas cap Molded splash guards Moonroof deflector Rear air deflectors Side window air deflectors Step/sill plates Tail lamp surrounds (black and chrome) Universal floor mats Accessories 231 Accessories For maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR as indicated on the Safety compliance certification label). Consult your dealer for specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of mobile communications systems - such as two-way radios, telephones and theft alarms - that are equipped with radio transmitters. Any such equipment installed in your vehicle should comply with FCC or CRTC regulations and should be installed only by a qualified service technician. • Mobile communications systems may harm the operation of your vehicle, particularly if they are not properly designed for automotive use or are not properly installed. When operated, such systems may cause the engine to stumble or stall or cause the transmission to be damaged or operate improperly. In addition, such systems may be damaged or their performance may be affected by operating your vehicle. If you intend on fitting a mobile radio such as a citizens band radio (CB), please refer to your local dealer for Ford recommended installation guidelines. Ask you dealer to reference the “Ford Mobile Radio Installation Guidelines.” (Citizens band [CB] transceivers, garage door openers and other transmitters with outputs of five watts or less will not ordinarily affect your vehicle’s operation.) • Ford cannot assume responsibility for any adverse effects or damage that may result from the use of such equipment. 232 Index Air bag supplemental restraint system ............................96–97, 100 and child safety seats ..............98 description ........................97, 100 disposal ....................................103 driver air bag ....................99, 101 indicator light .................100, 102 operation ...........................99, 101 passenger air bag .............99, 101 side air bag ..............................100 Air cleaner filter ...............215, 220 All Wheel Drive (AWD), driving off road .........................130 Ambulance packages ....................7 Antifreeze (see Engine coolant) ................196 Anti-lock brake system (see Brakes) ..............................119 Anti-theft system ........................73 arming the system ....................73 disarming a triggered system ..74 Audio system Single CD ..................................15 Audio system (see Radio) ................15, 18, 22, 26 Automatic transaxle fluid, adding ............................212 fluid, checking ........................212 Automatic transmission ............121 driving an automatic overdrive .................................124 fluid, refill capacities ..............220 fluid, specification ..................225 Auxiliary power point .................49 Index Axle lubricant specifications ..................223, 225 refill capacities ........................220 Battery .......................................194 acid, treating emergencies .....194 jumping a disabled battery ....162 maintenance-free ....................194 replacement, specifications ...220 servicing ..................................194 BeltMinder ...................................92 Brakes ........................................119 anti-lock ...................................119 anti-lock brake system (ABS) warning light ...........................119 fluid, checking and adding ....211 fluid, refill capacities ..............220 fluid, specifications .........223, 225 lubricant specifications ..223, 225 parking ....................................120 shift interlock ..........................121 Bulbs ............................................39 Calculating load ........................143 Capacities for refilling fluids ....220 Cargo area shade ........................55 Cassette tape player .............15, 22 CD-single premium ...............18, 26 Cell phone use ............................54 Certification Label ....................227 Changing a tire .........................157 Child safety restraints ..............103 child safety belts ....................103 233 Index Child safety seats ......................106 attaching with tether straps ..110 in front seat ............................108 in rear seat ..............................108 Cleaning your vehicle engine compartment ..............181 instrument panel ....................183 interior .....................................184 interior trim ............................183 plastic parts ............................182 washing ....................................180 waxing .....................................180 wheels ......................................181 wiper blades ............................183 Climate control (see Air conditioning or Heating) ......31–32 Clock adjust Single CD ..................................15 Clutch fluid ..................................211, 214 operation while driving ..........126 recommended shift speeds ....128 Console ........................................53 overhead ....................................46 Controls power seat .................................76 Coolant checking and adding ..............196 refill capacities ................199, 220 specifications ..................223, 225 Cruise control (see Speed control) ....................51 Customer Assistance ................148 Ford accessories for your vehicle .....................................185 Ford Extended Service Plan ..........................................172 Getting assistance outside the U.S. and Canada ..............176 234 Getting roadside assistance ...148 Getting the service you need .........................................170 Ordering additional owner’s literature .................................177 The Dispute Settlement Board .......................................173 Utilizing the Mediation/Arbitration Program ...................................176 Daytime running lamps (see Lamps) ................................34 Defrost rear window ..............................33 Dipstick automatic transmission fluid ..........................................212 engine oil .................................190 Doors lubricant specifications ..........223 Driving under special conditions ..................126, 133, 135 sand .........................................134 snow and ice ...........................136 through water .................134, 140 Emergencies, roadside jump-starting ..........................162 Emission control system ..........208 Engine ........................................225 cleaning ...................................181 coolant .....................................196 idle speed control ...................194 lubrication specifications ..................223, 225 refill capacities ........................220 service points ..................188–189 starting after a collision .........149 Engine block heater .................118 Engine oil ..................................190 checking and adding ..............190 dipstick ....................................190 filter, specifications ........193, 220 recommendations ...................193 refill capacities ........................220 specifications ..................223, 225 Exhaust fumes ..........................118 Fluid capacities .........................220 Foglamps .....................................34 Four-Wheel Drive vehicles driving off road .......................131 indicator light .........................130 preparing to drive your vehicle .....................................121 Fuel ............................................201 calculating fuel economy .......205 cap ...........................................203 capacity ...................................220 choosing the right fuel ...........203 comparisons with EPA fuel economy estimates .................208 detergent in fuel .....................204 filling your vehicle with fuel ...........................201, 203, 205 filter, specifications ........205, 220 fuel pump shut-off switch .....149 improving fuel economy ........205 octane rating ...................204, 225 quality ......................................204 running out of fuel .................205 safety information relating to automotive fuels .....................201 Index Fuses ..................................150–151 Garage door opener ....................46 Gas cap (see Fuel cap) ............203 Gas mileage (see Fuel economy) ...................................205 Gauges .........................................13 GAWR (Gross Axle Weight Rating) .......................................141 calculating ...............................143 definition .................................141 driving with a heavy load ......141 location ....................................141 GVWR (Gross Vehicle Weight Rating) .......................................141 calculating .......................141, 143 definition .................................141 driving with a heavy load ......141 location ....................................141 Hazard flashers .........................149 Head restraints .....................75, 77 Headlamps ...................................34 aiming ........................................36 autolamp system .................34, 48 bulb specifications ....................39 daytime running lights .............34 flash to pass ..............................35 high beam .................................35 replacing bulbs .........................39 turning on and off ....................34 Heating heater only system ...................31 Hood ..........................................187 Ignition ...............................115, 225 235 Index Infant seats (see Safety seats) .....................106 Inspection/maintenance (I/M) testing ........................................210 Instrument panel cleaning ...................................183 cluster ........................................10 lighting up panel and interior .......................................35 anti-lock brakes (ABS) ..........119 Load limits .................................141 GAWR ......................................141 GVWR ......................................141 trailer towing ..........................141 Loading instructions .................142 Locks childproof ..................................66 Lubricant specifications ...223, 225 Jack ............................................157 positioning ...............................157 storage .....................................157 Jump-starting your vehicle ......162 Keys positions of the ignition .........115 Lamps autolamp system .......................34 bulb replacement specifications chart ..................39 cargo lamps ...............................35 daytime running light ...............34 fog lamps ...................................34 headlamps .................................34 headlamps, flash to pass ..........35 instrument panel, dimming .....35 interior lamps .....................37–39 replacing bulbs .............39, 42–43 Lane change indicator (see Turn signal) ........................37 Liftgate ........................................55 Lights, warning and indicator ....10 236 Manual transaxle .......................126 fluid, checking and adding ....214 reverse .....................................128 Manual transmission fluid capacities ........................220 lubricant specifications ..........225 Mirrors .........................................48 automatic dimming rearview mirror ........................................48 fold away ...................................51 heated ........................................51 side view mirrors (power) .......50 Moon roof ....................................54 Motorcraft parts ................205, 220 Octane rating ............................204 Oil (see Engine oil) ..................190 Overdrive ...................................123 Parking .......................................129 Parking brake ............................120 Parts (see Motorcraft parts) ....220 Power distribution box (see Fuses) ...............................154 Power point .................................49 Power steering ..........................120 fluid, checking and adding ....211 fluid, refill capacity ................220 fluid, specifications .........223, 225 Power Windows ...........................49 Preparing to drive your vehicle ........................................121 Radio ..........................15, 18, 22, 26 Single CD ..................................15 Rear window defroster ...............33 Relays ........................................150 Remote entry system illuminated entry ......................70 locking/unlocking doors ...........65 Reverse sensing system ...........139 Roadside assistance ..................148 Roof rack .....................................56 Safety Belt Maintenance ............96 Safety belts (see Safety restraints) ..............................85–89 Safety defects, reporting ..........179 Safety restraints ....................85–90 belt minder ...............................92 extension assembly ..................91 for adults .............................86–89 for children .............................103 lap belt ......................................90 safety belt maintenance ...........96 warning light and chime ..........91 Index Safety seats for children ..........106 Seat belts (see Safety restraints) ...............85 Seats ............................................75 child safety seats ....................106 heated ........................................77 Servicing your vehicle ..............186 Snowplowing .................................7 Spare tire (see Changing the Tire) ...........................................157 Spark plugs, specifications .....................220, 225 Special notice ambulance conversions ..............7 utility-type vehicles ....................7 Specification chart, lubricants ...........................223, 225 Speed control ..............................51 Starting your vehicle ........................115–116, 118 jump starting ..........................162 Steering wheel tilting .........................................45 Stereo Single CD ..................................15 Temperature control (see Climate control) .................31 Tilt steering wheel ......................45 Tires ...........................157, 216–217 changing ..........................157–158 checking the pressure ............217 replacing ..................................218 rotating ....................................217 snow tires and chains ............219 237 Vehicle Identification Number (VIN) ..........................................228 Vehicle loading ..........................141 Ventilating your vehicle ...........118 Warning lights (see Lights) .......10 Washer fluid ..............................190 Water, Driving through .............140 Windows power .........................................49 rear wiper/washer .....................44 Windshield washer fluid and wipers checking and adding fluid .....190 liftgate reservoir .....................190 operation ...................................44 replacing wiper blades .............45 Wrecker towing .........................168 Index tire grades ...............................217 treadwear ................................216 Towing .......................................143 recreational towing .................147 trailer towing ..........................143 wrecker ....................................168 Transaxle fluid, checking and adding (manual) .................................214 manual operation ....................126 Transmission automatic operation ...............121 fluid, checking and adding (automatic) .............................212 fluid, refill capacities ..............220 lubricant specifications ..223, 225 ..................................37 Turn signal Vehicle dimensions ...................225 238 239 240 Table of Contents Table of Contents Introduction Instrument Cluster Warning and control lights Gauges Entertainment Systems AM/FM stereo with CD AM/FM stereo cassette with CD Climate Controls Heater only Manual heating and air conditioning Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control 10 10 13 15 15 18 31 31 32 34 34 37 39 44 44 45 49 50 51 65 65 65 70 75 75 85 96 103 115 115 119 121 143 148 148 149 149 150 157 162 168 170 179 Table of Contents Locks and Security Keys Locks Anti-theft system Seating and Safety Restraints Seating Safety restraints Air bags Child restraints Driving Starting Brakes Transmission operation Trailer towing Roadside Emergencies Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Jump starting Wrecker towing Customer Assistance Reporting safety defects (U.S. only) Cleaning Maintenance and Specifications Engine compartment Engine oil Battery Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications Accessories Index Table of Contents 180 186 188 190 194 201 215 220 220 223 229 233 All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and without incurring obligation. Copyright © 2002 Ford Motor Company Introduction Introduction CALIFORNIA Proposition 65 Warning WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle the greater the safety and pleasure you will derive from driving it. For more information on Ford Motor Company and its products visit the following website: • In the United States: www.ford.com • In Canada: www.ford.ca • In Australia: www.ford.com.au • In Mexico: www.ford.com.mx Additional owner information is given in separate publications. This Owner’s Guide describes every option and model variant available and therefore some of the items covered may not apply to your particular vehicle. Furthermore, due to printing cycles it may describe options before they are generally available. Remember to pass on the Owner’s Guide when reselling the vehicle. It is an integral part of the vehicle. Fuel pump shut-off switch In the event of an accident the safety switch will automatically cut off the fuel supply to the engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside emergencies chapter. Introduction SAFETY AND ENVIRONMENT PROTECTION Warning symbols in this guide How can you reduce the risk of personal injury and prevent possible damage to others, your vehicle and its equipment? In this guide, answers to such questions are contained in comments highlighted by the warning triangle symbol. These comments should be read and observed. Warning symbols on your vehicle When you see this symbol, it is imperative that you consult the relevant section of this guide before touching or attempting adjustment of any kind. Protecting the environment We must all play our part in protecting the environment. Correct vehicle usage and the authorized disposal of waste cleaning and lubrication materials are significant steps towards this aim. Information in this respect is highlighted in this guide with the tree symbol. BREAKING-IN YOUR VEHICLE Your vehicle does not need an extensive break-in. Try not to drive continuously at the same speed for the first 1,600 km (1,000 miles) of new vehicle operation. Vary your speed to allow parts to adjust themselves to other parts. Drive your new vehicle at least 800 km (500 miles) before towing a trailer. Do not add friction modifier compounds or special break-in oils during the first few thousand kilometers (miles) of operation, since these additives may prevent piston ring seating. See Engine oil in the Maintenance and specifications chapter for more information on oil usage. Introduction SPECIAL NOTICES Special instructions For your added safety, your vehicle is fitted with sophisticated electronic controls. Please read the section Supplemental Restraint System (SRS) in the Seating and safety restraints chapter. Failure to follow the specific warnings and instructions could result in personal injury. Front seat mounted rear facing child or infant seats should NEVER be used in front of a passenger side air bag unless the air bag can be and is turned OFF. Data Recording Computers in your vehicle are capable of recording detailed data potentially including but not limited to information such as: • the use of restraint systems including seat belts by the driver and • information about the performance of various systems and modules in • information related to engine, throttle, steering, brake or other system the vehicle, and passengers, status. Any of this information could potentially include information regarding how the driver operates the vehicle potentially including but not limited to information regarding vehicle speed, brake or accelerator application or steering input. This information may be stored during regular operation or in a crash or near crash event. This stored information may be read out and used by: • Ford Motor Company. • service and repair facilities. • law enforcement or government agencies. • others who may assert a right or obtain your consent to know such information. Introduction Emission warranty The New Vehicle Limited Warranty includes Bumper-to-Bumper Coverage, Safety Restraint Coverage, Corrosion Coverage, and 7.3L Power Stroke Diesel Engine Coverage. In addition, your vehicle is eligible for Emissions Defect and Emissions Performance Warranties. For a detailed description of what is covered and what is not covered, refer to the Warranty Guide that is provided to you along with your Owner’s Guide. Notice to owners of pickup trucks and utility type vehicles Utility vehicles have a significantly higher rollover rate than other types of vehicles. Before you drive your vehicle, please read this Owner’s Guide carefully. Your vehicle is not a passenger car. As with other vehicles of this type, failure to operate this vehicle correctly may result in loss of vehicle control, vehicle rollover, personal injury or death. Be sure to read Driving off road in the Driving chapter. Using your vehicle with a snowplow Do not use this vehicle for snowplowing. Using your vehicle as an ambulance Do not use this vehicle as an ambulance. Your vehicle is not equipped with the Ford Ambulance Preparation Package. Middle East/North Africa vehicle specific information For your particular global region, your vehicle may be equipped with features and options that are different from the ones that are described in this Owner Guide; therefore, a supplement has been supplied that complements this book. By referring to the pages in the provided supplement, you can properly identify those features, recommendations and specifications that are unique to your vehicle. Refer to this Owner Guide for all other required information and warnings. Introduction These are some of the symbols you may see on your vehicle. Vehicle Symbol Glossary Safety Alert See Owner’s Guide Fasten Safety Belt Air Bag-Front Air Bag-Side Child Seat Child Seat Installation Warning Child Seat Tether Anchor Anti-Lock Brake System Child Seat Lower Anchor Brake System Brake Fluid - Non-Petroleum Based Traction Control AdvanceTrac娂 Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Defrost/Demist Rear Window Defrost/Demist Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Power Window Lockout Interior Luggage Compartment Release Symbol Panic Alarm Engine Oil Engine Coolant Engine Coolant Temperature Do Not Open When Hot Battery Avoid Smoking, Flames, or Sparks Battery Acid Explosive Gas Fan Warning Power Steering Fluid Maintain Correct Fluid Level MAX MIN Emission System Engine Air Filter Passenger Compartment Air Filter Jack Check fuel cap Low tire warning Instrument Cluster Instrument Cluster WARNING LIGHTS AND CHIMES Warning lights and gauges can alert you to a vehicle condition that may become serious enough to cause expensive repairs. A warning light may illuminate when a problem exists with one of your vehicle’s functions. Many lights will illuminate when you start your vehicle to make sure the bulb works. If any light remains on after starting the vehicle, have the respective system inspected immediately. Service engine soon: The Service engine soon indicator light illuminates when the ignition is first turned to the ON position to check the bulb. Solid illumination after the engine is started indicates the On Board Diagnostics System (OBD-II) has detected a malfunction. Refer to On board diagnostics (OBD-II) in the Maintenance and Specifications chapter. If the light is blinking, engine misfire is occurring which could damage your catalytic converter. Drive in a moderate fashion (avoid heavy acceleration and deceleration) and have your vehicle serviced immediately. Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. Check fuel cap: Illuminates when the fuel cap may not be properly installed. Continued driving with this light on may cause the Service engine soon warning light to come on. Refer to Fuel filler cap in the Maintenance and Specifications chapter. FUEL CAP CHECK 10 Instrument Cluster Brake system warning light: To confirm the brake system warning light is functional, it will momentarily illuminate when the ignition is turned to the ON position when the engine is not running, or in a position between ON and START, or by applying the parking brake when the ignition is turned to the ON position. If the brake system warning light does not illuminate at this time, seek service immediately from your dealership. Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your servicing dealership. BRAKE Driving a vehicle with the brake system warning light on is dangerous. A significant decrease in braking performance may occur. It will take you longer to stop the vehicle. Have the vehicle checked by your dealer immediately. ABS Anti-lock brake system: Illuminates indicating an ABS fault. If the lamp stays on for more than a few seconds, then an ABS fault is indicated, have the system serviced immediately. Normal braking is still functional unless the brake warning light also is illuminated. Air bag readiness: If this light fails to illuminate when ignition is turned to ON, continues to flash or remains on, have the system serviced immediately. A chime will also sound when a malfunction in the supplemental restraint system has been detected. Safety belt: Reminds you to fasten your safety belt. A chime will also sound to remind you to fasten your safety belt. Charging system: Illuminates when the battery is not charging properly. 11 Instrument Cluster Engine oil pressure: Illuminates when the oil pressure falls below the normal range, refer to Engine oil in the Maintenance and specifications chapter. Low fuel: Illuminates when the fuel level in the fuel tank is at, or near empty (refer to Fuel gauge in this chapter). O/D OFF Overdrive off: Illuminates when the overdrive function of the transmission has been turned off, refer to the Driving chapter. If the light flashes steadily, have the system serviced immediately. Four wheel drive indicator (if 4x4 equipped): Illuminates when four-wheel drive is engaged. Anti-theft system: Flashes when the Securilock娂 Passive Anti-theft System has been activated. Speed control: Illuminates when the speed control is activated. Turns off when the speed control system is deactivated. Door ajar: Illuminates when the ignition is in the ON position and any door is open. Turn signal: Illuminates when the left or right turn signal or the hazard lights are turned on. If the indicators stay on or flash faster, check for a burned out bulb. High beams: Illuminates when the high beam headlamps are turned on. 12 Instrument Cluster Key-in-ignition warning chime: Sounds when the key is left in the ignition in the OFF/LOCK or ACC position and the driver’s door is opened. Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (and the key is not in the ignition) and the driver’s door is opened. GAUGES Speedometer: Indicates the current vehicle speed. 60 80 100 120 140 100 160 180 km/h 120 40 80 60 40 20 20 MPH Engine coolant temperature gauge: Indicates engine coolant temperature. At normal operating temperature, the needle will be in the normal range (between “H” and “C”). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. Never remove the coolant reservoir cap while the engine is running or hot. 13 Instrument Cluster Odometer: Registers the total kilometers (miles) of the vehicle. Trip odometer: Registers the kilometers (miles) of individual journeys. To reset, tap on the trip reset button to toggle the display between the trip and the odometer. Holding the reset button for one or two seconds will reset the trip odometer to zero. Tachometer: Indicates the engine speed in revolutions per minute. Driving with your tachometer pointer continuously at the top of the scale may damage the engine. Fuel gauge: Indicates approximately how much fuel is left in the fuel tank (when the ignition is in the ON position). The fuel gauge may vary slightly when the vehicle is in motion or on a grade. Refer to Filling the tank in the Maintenance and Specifications chapter for more information. 14 Entertainment Systems Entertainment Systems AM/FM STEREO / SINGLE CD RADIO 13 14 15 16 17 18 VOL - PUSH ON 12 11 SEEK TUNE DISCS AM FM CD BASS TREB FM1 ST BAL FADE DISC SCN CLK EJ COMP CD CD SHUFFLE 10 1. Balance: Press sound to the left/right speakers. to shift 2. Fade: Press sound to the front/rear speakers. to shift 3. SCN (Scan): Press to hear a brief sampling of all listenable stations or CD tracks. Press again to stop. 4. CLK: To set the hour, press and hold CLK and press SEEK to decrease hours. To set the minute, press and hold CLK and press TUNE to decrease or increase the minutes. or increase the CLK 15 Entertainment Systems 5. EJ (eject): Press to eject a CD. 6. COMP (Compression): In CD mode, press to bring louder and softer levels into more comfortable listening level. The compression icon (c) will appear in the display. 7. Shuffle: Press to listen to the tracks on the CD in random order. Press again to turn off. 8. Memory presets: To set a station: Select frequency band AM/FM; tune to a station. Press and hold a preset button until sound returns. This radio is equipped with six station memory preset controls which allow you to set up to six AM stations and 12 FM stations (six in FM1 and six in FM2). 9. CD: desired selection is reached. Press and hold until CD CD SHUFFLE SHUFFLE 10. desired selection is reached. CD: Press and hold until 11. Tune / Discs: In radio mode, press to move up or down the frequency band in individual increments. 12. Seek: Press and release for previous/next SEEK strong station, selection or track. 13. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. 14. CD: Press to enter CD mode or to play a CD already loaded into the system. 16 Entertainment Systems 15. AM/FM: Press to choose a frequency band in radio mode. 16. Bass: Press increase/decrease the bass output. to 17. Treble: Press increase/decrease the treble output. to DISC 18. CD door: Insert a CD printed side up. CD unit are designed to play commercially pressed 12 cm (4.75 in) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player. The label may peel and cause the CD to become jammed. It is recommended that homemade CDs be identified with permanent felt tip marker rather than adhesive labels. Ball point pens may damage CDs. Please contact your dealer for further information. 17 Entertainment Systems PREMIUM AM/FM STEREO/CASSETTE/SINGLE CD 1. Power/volume: Press to turn ON/OFF; turn to increase/decrease volume. SCAN 2. Scan: Press to hear a brief sampling of all listenable stations, tape selections or CD tracks. Press again to stop. 3. CD Door: Insert a CD with the label side up. CD unit are designed to play commercially pressed 12 cm (4.75 in) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should 18 Entertainment Systems not be inserted into the CD player. The label may peel and cause the CD to become jammed. It is recommended that homemade CDs be identified with permanent felt tip marker rather than adhesive labels. Ball point pens may damage CDs. Please contact your dealer for further information. 4. Cassette door: Insert the cassette with the opening to the right. 5. Eject: Press to eject the cassette/CD. The radio will resume playing. 6. Tape: Press to start tape play. Press to stop tape during rewind/fast forward. CD: Press to start CD play. With the dual media audio, press CD to toggle between single CD and CD changer play (if equipped). 7. Mute: Press to MUTE playing media; press again return to playing media. 8. Auto: Press to set first six strongest stations (if available) into AM, FM1 or FM2 memory buttons; press again to return to normal stations. 9. Clock: Press and hold to set the clock. Press the decrease hours or SEEK increase hours. Press the to TUNE SEEK to 19 Entertainment Systems to increase minutes. If your vehicle to decrease minutes or TUNE has a stand alone clock this control will not function. 10. Balance: Press BAL; then press SEL left/right speakers. to shift sound to the Fade: Press FADE; then press SEL rear/front speakers. to shift sound to the 11. Memory preset buttons: To set a station: Select frequency band AM/FM, tune to a station, press and hold a preset button until sound returns. 12. Shuffle (CD): Press to play tracks in random order. 13. Compression (CD): Press to bring soft and loud passages together for a more consistent listening level. Dolby威 noise reduction: 14. Works in tape mode only. Reduces tape noise and hiss; press to activate/deactivate. The Dolby威 noise reduction system is manufactured under license from Dolby Laboratories Licensing Corporation. Dolby威 and the double-D symbol are registered trademarks of Dolby Laboratories Licensing Corporation. 15. Side 1–2: Works in tape mode only. Press to play reverse side of the tape. 20 16. Fast Forward (FF): Press for a slow advance, press and hold for a fast advance. 17. Rewind (REW): Press for a slow rewind, press and hold for a fast rewind. 18. Select (SEL): Use with Bass, Treble, Balance and Fade controls. 19. Bass: Press BASS; then press to decrease/increase SEL the bass output. Treble: Press TREB; then press SEL the treble output. to decrease/increase 20. Tune: Works in radio mode only. Press TUNE frequency down/up. to change 21. Seek: Press and release for previous/next SEEK strong station, selection or track. 22. AM/FM: Press to select AM/FM1/FM2 frequency band. Entertainment Systems FF REW SEL SEEK TUNE SEEK TUNE 21 Entertainment Systems PREMIUM IN-DASH SIX CD SOUND SYSTEM 15 16 17 SHUF SCAN DISC TUNE SEEK REW FF COMP 14 13 LOAD PUSH ON MUTE EJ BASS BAL SEL TREB FADE AM FM CD MENU 12 11 10 AUDIOPHILE IN-DASH SIX CD SOUND SYSTEM 1. Seek: Press and release for previous/next SEEK strong station, selection or track. 22 Entertainment Systems 2. Rewind: In CD mode, press until desired selection is reached. Fast forward: In CD mode, press until desired selection is reached. 3. COMP (Compression): The compression feature operates in CD mode and brings soft and loud CD passages together for a more consistent listening level. Press the COMP control until COMP ON is displayed. DSP DSP (Digital Signal Processing) (if equipped): Press to enter DSP mode – allows you to engage/disengage DSP status, and choose signal modes of JAZZ CLUB, HALL, CHURCH, STADIUM. Ambiance (if equipped): This feature gives the feeling of “being there” to your music, creating increased clarity as well as an open and spacious feel to the music. Press DSP to access the ambiance menu. Press SEL to engage/disengage. Turn the volume control to increase/decrease the level of ambiance. Press DSP again to change the occupancy mode to optimize sound for ALL SEATS, DRIVER SEAT or REAR SEAT. 4. Mute: Press to MUTE playing media; press again return to playing media 5. Eject: Press to eject a CD. Press and hold to eject all loaded discs. to decrease/increase 6. Bass: Press BASS; then press SEL the bass output. Treble: Press TREB; then press SEL the treble output. to decrease/increase 7. Select: Use with Bass, Treble, Balance and Fade controls to adjust levels. 23 Entertainment Systems to shift sound to the 8. Balance: Press BAL; then press to shift sound to the SEL left/right speakers. Fade: Press FADE; then press SEL rear/front speakers. 9. Menu: Press MENU and SEL to access clock mode, RDS on/off, Traffic announcement mode and Program type mode. On Audiophile audios, press MENU to access the compression feature. Press SEL to turn the feature ON or OFF. Traffic: Allows you to hear traffic broadcasts. With the feature ON, press SEEK or SCAN to find a station broadcasting a traffic report (if it is broadcasting RDS data). Traffic information is not available in most U.S. markets. FIND Program type: Allows you to search RDS-equipped stations for a certain category of music format: Classic, Country, Info, Jazz, Oldies, R&B, Religious, Rock, Soft, Top 40. Show TYPE: Displays the station’s call letters and format. Compression: Brings soft and loud CD passages together for a more consistent listening level. Setting the clock: Press MENU until SELECT HOUR or SELECT MINUTE is displayed. Use SEL to manually increase ( 10. Memory presets: To set a station: Select frequency band AM/FM; tune to a station, press and hold a preset button until sound returns. 11. CD: Press to select CD mode. ) or decrease ) the hours/minutes. Press MENU again to disengage clock mode. 12. AM/FM: Press to select AM/FM frequency band. Autostore: Allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2 . Press and momentarily hold AM/FM. 24 Entertainment Systems AUTOSTORE will flash on the display. When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong stations, the system will store the last one in the remaining presets. Press again to disengage. 13. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. Automatic Volume Control (if equipped): Changes the volume automatically and slightly with vehicle speed to compensate for road and wind noise. The recommended level is 1–3. Level 0 turns the speed sensitive volume off and level 7 is the maximum setting. Press and hold the volume control for five seconds. Then, press the SEL control to increase or decrease volume levels. The selected level will appear in the display. 14. Load: Press to load a CD. Press and hold to load up to six discs. 15. Shuffle: Press to play tracks in random order. 16. Scan: Press for a brief sampling of radio stations or CD tracks. Press again to stop. 17. Disc tune: Radio: Press or the radio frequency band. CD: Press on the CD. to manually tune down or up to select the previous track or to select the next track 25 Entertainment Systems MACH姞 MP3 AUDIO SYSTEM 1. Balance: Press sound to the left/right speakers. to shift 2. Fade: Press to shift sound to the rear/front speakers. 3. Scan: Press to hear a brief sampling of all listenable radio stations, CD or MP3 tracks. Press again to stop. 4. CLK: To set the clock press and hold the CLK control for the following functions: • To set the hour, press SEEK to the hours. • To set the minutes, press TUNE DIR the minutes. Release CLK to save the clock settings. Press CLK again to return the display to radio mode. control to decrease or increase to decrease or increase 26 Entertainment Systems 5. EJ (Eject): Press to stop and eject a disc. If a disc is ejected and not removed, the player will automatically reload the disc and return to radio mode. 6. COMP (Compression): In CD and MP3 mode, press to adjust the soft and loud sounds together for a more consistent listening level. The compression icon (c) will illuminate in the display. 7. Shuffle: Press to engage random play on the CD or MP3 disc. SHF then ON will briefly appear in the display. Press SEEK to select another random track on the disc. Press shuffle again to disable. 8. Repeat: Press to repeat the current track. (Fast forward): Press CD (Rewind): Press and 9. CD and hold until the desired selection point is reached. This function is not enabled in MP3 mode. 10. hold until the desired selection point is reached. This function is not enabled in MP3 mode. 11. MP3 directory: Allows you to listen to songs in MP3 flat file mode and MP3 directory mode. • Insert a MP3 disc to engage in the flat file mode. The MP3 icon will be • While in the MP3 flat file mode, press the MP3 DIR control to enter displayed. into the directory mode. Press the TUNE DIR control to change directories. The MP3 icon and the DIR icon will be displayed. 12. Track: Press to locate a specific MP3 track or directory. TRAC will appear in the display. Rotate volume control to advance or reverse through the tracks or directories. The MP3 icon will flash in the display while the MACH威 track function is enabled. 27 Entertainment Systems 13. Memory presets: To set a station: Select frequency band AM/FM; tune to a station, press and hold a preset button until sound returns. 14. CD door: Insert a CD with the label side up. 15. Tune/Directory: Press TUNE to change the radio DIR frequency down/up or change the MP3 directories. 16. Seek: Press and release SEEK strong station selection or CD and MP3 tracks. 17. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. for previous/next 18. CD: Press CD to play a CD or MP3 disc. When the MP3 disc is loaded, CD and LOAD will appear on the display. The display will briefly show the total number of tracks on the disc as TXXX (XXX=number of tracks). 19. AM/FM: Press to select a frequency band in radio mode. 20. Bass: Press decrease/increase the bass output. to 28 Entertainment Systems 21. Treble: Press decrease/increase the treble output. to RADIO FREQUENCIES AM and FM frequencies are established by the Federal Communications Commission (FCC) and the Canadian Radio and Telecommunications Commission (CRTC). Those frequencies are: AM - 530, 540–1700, 1710 kHz FM- 87.7, 87.9–107.7, 107.9 MHz weaker the signal and the weaker the reception. RADIO RECEPTION FACTORS There are three factors that can affect radio reception: • Distance/strength: The further you travel from an FM station, the • Terrain: Hills, mountains, tall buildings, power lines, electric fences, traffic lights and thunderstorms can interfere with your reception. • Station overload: When you pass a broadcast tower, a stronger signal may overtake a weaker one and play while the weak station frequency is displayed. CASSETTE/PLAYER CARE Do: • Use only cassettes that are 90 minutes long or less. • Tighten very loose tapes by inserting a finger or pencil into the hole • Remove loose labels before inserting tapes. • Allow tapes which have been subjected to extreme heat, humidity or • Clean the cassette player head with a cassette cleaning cartridge after cold to reach a moderate temperature before playing. and turning the hub. 10–12 hours of play to maintain good sound/operation. Don’t: • Expose tapes to direct sunlight, extreme humidity, heat or cold. • Leave tapes in the cassette player for a long time when not being played. 29 Entertainment Systems CD/CD PLAYER CARE Do: • Handle discs by their edges only. Never touch the playing surface. • Inspect discs before playing. Clean only with an approved CD cleaner and wipe from the center out. of time. Don’t: • Expose discs to direct sunlight or heat sources for extended periods • Insert more than one disc into each slot of the CD changer magazine. • Clean using a circular motion. CD units are designed to play commercially pressed 12 cm (4.75 in) audio compact discs only. Due to technical incompatibility, certain recordable and re-recordable compact discs may not function correctly when used in Ford CD players. Irregular shaped CDs, CDs with a scratch protection film attached, and CDs with homemade paper (adhesive) labels should not be inserted into the CD player. The label may peel and cause the CD to become jammed. It is recommended that homemade CDs be identified with permanent felt tip marker rather than adhesive labels. Ball point pens may damage CDs. Please contact your dealer for further information. AUDIO SYSTEM WARRANTY AND SERVICE Refer to the Warranty Guide for audio system warranty information. If service is necessary, see your dealer or qualified technician. 30 Climate Controls Climate Controls HEATER ONLY SYSTEM 1. Fan speed adjustment: Controls the volume of air circulated in the vehicle. 2. Air flow selections: Controls the direction of the airflow in the vehicle. See the following for a brief description on each control. : Distributes outside air through the instrument panel vents. O (OFF): Outside air is shut out and the fan will not operate. : Distributes outside air through the instrument panel vents and the floor vents. : Distributes outside air through the floor vents. : Distributes outside air through the windshield defroster vents and floor vents. : Distributes outside air through the windshield defroster vents. 3. Temperature selection: Controls the temperature of the airflow in the vehicle. position. the air flow selector in the

Boost Classifieds - Car Advice, Reviews, Events & Classifieds

2003 Ford Escape Owners Manual