1994 Chevrolet S10 Owners Manual

. .

The fuse block is in the instrument panel on the driver’s side. Remove the cover by turning the fastener to the left. Then you can remove fuses with a fuse extractor.

Spare fuses are provided, however if you ever have a problem on the road and don’t have a spare fuse, you can “borrow” one of the correct value. Just pick some feature of your vehicle that you can get along without-like the its fuse, if it is of the value you need. radio or cigarette lighter-and use Replace it as soon as you can. See “Fuses and Circuit Breakers” in this section. TO reinstall the fuse panel cover, push in and turn the fastener to the right.

6-72

Capacities and Specification Charts Replacement Parts Replacement part numbers listed in this section are based on the latest information available at the time of printing, and are subject to change. If a part listed in this manual is not the same as the part used in your vehicle when it was built, or if you have any questions, please contact your GM truck dealer. Engine Identification

Engine Type VZN Code Fuel Systems Emissions

2.2L L4 MPI* LD

*Multi-Port Fuel Injection **Throttle-Body Fuel Injection ***Central-Port Fuel Injection

Wheel Nut Torque DESCRIPTION

4.3L V6 TBI** LD

4.3L V6 CPI* * * LD

TORQUE

Base or Optional Wheel

35 ft. lbs. (130 Nom)

Cooling System Capacity

ENGINE

2.2L 4.3L 4.3L

VIN

QUANTITY* 11.5 Quarts (1 1 Liters) 12.1 Quarts (11.5 Liters) 12.1 Quarts (11.5 Liters)

*All quantities are approximate. After refill, the level MUST be rechecked.

6-73

Crankcase Capacity ENGINE

VIN

2.2L 4.3L 4.3L

QUANTITY WITH

QUANTITY FILTER* FILTER*

WITHOUT 4 Quarts (3.8 Liters) 4.5 Quarts 4 Quarts.(3.8 Liters) 4 Quarts (3.8 Liters) 4.5 Quarts

(4.3 Liters) 4.5 Quarts (4.3 Liters) (4.3 Liters)

*All quantities are approximate. After refill, the level MUST be rechecked. Fuel Tank Capacity

TYPE

Standard Tank

QUANTITY*

20 Gallons (76 Liters.)

*All quantities are approximate.

Lamp and Bulb Data

LAMPS

QUANTITY

TRADE NO.

EXTERIOR Headlamps (Sealed Beam) Headlamps (Composite)

Backup Lamp License Lamp (w/o Bumper) License Lamp (Step Bumper) Tail and Stop Lamps Marker Lamp-Front Marker Lamp-Rear Parking and Signal Lamp Underhood Lamp CHMSL?$

?Standard Cluster $Tach Cluster

2E1H

H9005 (HI) H9006 (LO)

3057 194 194 3057 194 194

3 157NA

93 577

6.- 74

INTERIOR Ash Tray Lamp Courtesy Lamp Dome Lamp Fol Hearer & A/C Controi Instrument Panel Compartment Lamp Rearview Mirror Lamps Sunshade Vanity Mirror Lamps

-Wheel Drive - lit,

lr

161 906 211-2 161 37 1003 2 12-2 74

INSTRUMENT CLUSTER LAMPS NOTE: A PC part number indicates that the bulb and base are one assembly and must be replaced as such.

LAMPS

QUANTITY

TRADE NO.

Anti-lock Brake Warning Indicator ?$ Brake System Warning Indicator?$ Check Gages Indicator?$ Daytime Running Lamps Indicator?$ Charging System Indicator?$ High Beam Indicator?$ Standard Cluster Illumination?

Tach Cluster Illumination$

Malfunction Indicator Lamp (Service Engine Soon)?$ Seat Belt Indicator?$ Turn Signal Indicator? Upshift Indicator?$

?Standard Cluster $Tach Cluster

PC74 PC74 PC74 PC74 PC74 PC74

PC 194 and

PC119

PC194 and

GE 194 PC74

PC74 PC74 PC74

r x l C P W R 7

30 A WDO

r 4 W D 1 20A

20 A PWR'] ACCY

r F O G 1 20 A A

N w

VI

Fuses and Circuit Breakers FUSE/CIRCUIT

NAME

BREAKER

CIRCUITS PROTECTED

PWR ACCY Power Door Locks PWR WDO Power Windows STOP/HAZ Stop Lamps, Hazard Lamps, Chime

Module

HORNDM Dome Lamp, Lighted Visor Mirror,

Glove Box Lamp, Horn, I/€' Courtesy Lamps, Power Mirrors

T/L CTSY Electric Shift Transfer Case Module,

Park Lamps, License Plate Lamps

GAUGES Auto Transmission, Alternator Field,

Variable Throttle Control, A/C Compressor, Cluster, Chime Module, Four-wheel Drive Indicator Lamp, Heated Oxygen Sensor, Daytime Running Lamps Module

(NOT USED)

6-76

FUSEKIRCUIT

BREAKER

NAME

CIRCUITS PROTECTED

HTR N C

Blower Motor, Temperature Door Motor

Auxiliary Outlets

PWR AUX Pwr (NOT USED) ECM BATT Engine Computer (Battery), ABS

Battery, Fuel Pump ECM IGN Engine Computer (Ignition),

Injectors, Engine Sensors Radio, Inside Rearview Mirror Map Lamps

10

11

12 13 14

15

16 17

18

19 20 21 22 23 24

RADIO

(NOT USED) RDO/BATT

ILLUM

DRL

TURN B/U

WIPER

BRAKE

4 WD

(NOT USED)

Clock, Radio Battery, CD Player Cluster Illumination, Ash Tray Lamp, Radio Illumination, Heater Lamp, Four-wheel Drive Illumination, Chime Module, Fog Lamp Switch Illumination, Daytime Running Lamps Daytime Running Lamps (Canada Only) Turn Signals, Backup Lamps Windshield Washer, Windshield Wiper Motor Speedometer, Anti-lock Braking System, Cruise Control Four-wheel Drive

FOG

Fog Lamps

(NOT USED) (NOT USED) (NOT USED)

Service Replacement Part and Filter Recommendations

Engine (VIN) Oil Filter Air Cleaner Filter PCV Valve Spark Plugs* Fuel Filter Radiator Cap

2.2L (4) PF47 A1163C cv9ooc AC908 GF48 1 RC36

4.3L (Z) PF52 A773C CV789C .CR43TSM GF48 1 RC36

4.3L (W) PF52 A1163C cv774c .CR43TSM GF481 RC36

*Use copper-cored resistor type spark plugs. Air Conditioning Refrigerants Not all air conditioning refrigerants are the same. system in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re not sure, ask your GM dealer. For additional information, see your “Warranty and Owner Assistance Information” booklet. Air Conditioning Refrigerant Capacity

If the air conditioning

TYPE R-l34a

. . Les are approximate.

*All q1

SYSTEM

c-60

QUANTITY* 30 oz. (35 kg)

NOTICE: R-134a refrigerant is not compatible with R-12 refrigerant in an air conditioning system. R-12 in an R-134a system will cause compressor failure, refrigerant oil sludge, or poor air conditioning system performance.

Scheduled Maintenance Services

Section

Maintenance Schedule I ................................ Maintenance Schedule I1 ................................

This section covers the maintenance required €or your vehicle . Your vehicle needs these services to retain its safety. dependability. and emission control performance . A Word About Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2 Your Vehicle and the Environment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2 Scheduled Maintenance Services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3 Selecting The Proper Maintenance Schedule ................... 7-3 7-4 7-6 Explanation of Scheduled Maintenance Services . . . . . . . . . . . . . . . . 7-7 Owner Checks and Services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-10 At Least Once a Month ................................... 7-10 At Least Four Times a Year ............................... 7-10 AtLeastOnceaYear .................................... 7-10 Periodic Maintenance Inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-12 Recommended Fluids & Lubricants . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-13 Maintenance Record ....................................... 7-15 Service Station Checks ..................................... 7-16

your new vehicle warranties . See your GM dealer for details . Have you purchased the GM Protection Plan? The Plan supplements

7-1

A Word About Maintenance We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands, or in many other ways. Because of all the different ways’pWple use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you will find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your GM dealer, the place many GM owners choose to have their maintenance work done. Your dealer can be relied upon to use proper parts and practices. Your Vehicle And The Environment Proper vehicle maintenance not only helps keep your vehicle working condition, but it also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance or the removal of important components can significantly affect the quality of the air we breathe. Improper fluid levels or even the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to help keep your vehicle in good condition, please maintain your vehicle properly.

in good

If you are skilled enough to do some work on your vehicle, you will probably want to get the service information GM publishes. You will find a list of publications and how to get them in Section 8, Customer Assistance Information. See “Service Publications” in the Index. The Maintenance Record provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this section. This will help you determine when your next maintenance should be done. In addition,

it is a good idea to keep your

7-2

maintenance receipts. They may be needed to qualify your vehicle for warranty repairs. Scheduled Mainfenance Services This part tells you the maintenance services you should have done and when you should schedule them. Your GM dealer knows your vehicle best and wants you to be happy with it. If you go to your dealer for all your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts. These schedules are for vehicles that:

carry passengers and cargo within the recommended limits. You will find these limits on your vehicle’s Certification Label. See “Loading Your Vehicle” in the Index. are driven on regular road surfaces, and within legal driving limits, as described in Section 4, Your Driving and the Road. are driven off-road in the recommended manner. See “Off Road Driving With Your Four-wheel Drive Vehicle” in the Index. use the proper fuel. See “Fuel” in the Index.

Selecting m e Proper Maintenance Schedule Your driving conditions and how you use your vehicle will help determine which schedule to use. The schedules are found later in this section. MAINTENANCE SCHEDULE I Is any one of these true for your vehicle?

you

less than 10 miles (16 k i

Most trips are less than 4 miles (6 kilometers). Most trips are temperatures are below freezing. The engine is at low speed most of the time (as in stop-and-go traffic, door-to-door- delivery, or other commercial uses). 0 You operate in dusty areas or off-road frequently.

.eters) and outside

l c

You tow a trailer.

If any one (or more) of these is true for your driving, follow Schedule. I. The chart for Schedule I has plus signs (+). MAINTENANCE SCHEDULE 11 Follow Schedule I1 ONLY if none of the above conditions are true. The chart for Schedule 11 has dots ( 0 ) .

7-3

MAlNTENANCE SCHEDULE I

Wheel

Rotation

Service

and Axle

13 Tire 14 Drive 15 Brake Systems Inspection** * An Emission Control Service ** See “Explanation of Scheduled Maintenance Services” in the Index $ The California Air Resources Board has determined that the failure to perform this

maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

TO801

7-4

MAINTENANCE SCHEDULE I (continued)

THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE DONE AFTER 60,000 MILES AT THE SAME INTERVALS. TO802

7-5

MAINTENANCE SCHEDULE I/

Item No.

Service

Miles (000) 7.5 Kilometers (000) 12.5 25 37.5 50 62.5

15 22.5 30 37.5

52.5 45 60

1 Engine Oil Change*-Every

12 Months, or Oil Filter Change*-Every 12 Months, or

2 Chassis Lubrication-Every

12 Months, or

System

Cooling

Service*

-Every 24 Months or

11 Fuel Tank, Cap and Lines

Inspection*$

12 Engine Accessory Drive Belt

Inspection*

75 87.5 100

Wheel Rotation

and

Tire

Drive

Axle Service

13 14 15 Brake Systems Inspection** * An Emission Control Service ** See “Explanation of Scheduled Maintenance Services” in the Index $ The California Air Resources Board has determined that the failure to perform this

maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE DONE AFTER 60,000 MILES AT THE SAME INTERVALS. TO803

Explanation Of Scheduled Maintenance Services Below are explanations of the services listed in the maintenance charts. The proper fluids and lubricants to use are listed whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. 1. ENGINE OIL AND OIL FILTER CHANGE* - ALWAYS USE

in this section. Make sure

API SERVICE SH OR SG ENERGY CONSERVING I1 OILS OF THE PROPER VISCOSITY. The “SH” or “SG’ designation may be shown alone or in combination with others, such as “SWCD”, or “SH, SG, CD,” or “SGKD”, etc. To determine the preferred viscosity oil for your vehicle’s engine (e.g. SAE 5W-30), see “Engine Oil” in the Index.

2. CHASSIS LUBRICATION - Lubricate the front suspension, ball

joints, brake pedal springs,

joint, steering linkage, and transfer case shift linkage, parking brake cable guides, propshaft splines, universal and clutch pedal springs at the intervals specified on the proper maintenance schedule, or at every engine oil change, whichever comes first . Ball joints should not be lubricated unless their temperature is 10°F (-12°C) or higher. When the weather is cold, let them warm up before lubricating them or they could be damaged. Also, be sure to check all the vehicle fluid levels at this time.

3. COOLING SYSTEM SERVICE* - Drain, flush and refill the

system with new or approved recycled coolant conforming to “GM Specification 6038-M” (4.3L engine) or “GM Specification 6043-M” (2.2L engine). See “Engine Coolant” in the Index for the proper coolant and mixture to use in your vehicle. Also inspect the hoses and replace them if they are cracked, swollen, or deteriorated. Clean the outside of the radiator and air conditioning condenser. Wash the radiator neck. To ensure proper operation, pressure test the radiator and cap.

4. AIR CLEANER FILTER REPLACEMENT* - Replace at specified intervals. Ask your dealer for the proper replacement intervals for your driving conditions.

5. FRONT WHEEL BEARING REPACK (%WHEEL DRIVE

ONLY) - Clean and repack the front wheel bearings at each brake relining, or at the specified interval, whichever comes first.

*An Emission Control Service

7-7

6. TRANSMISSION SERVICE:

Automatic Transmission - Change the transmission fluid and filter every 15,000 miles (25 000 km) one or more of these conditions:

he vehicle is mainly driven under

0 In heavy city traffic. 0 Where the outside temperature regularly reaches 90°F (32°C) or

higher.

0 In hilly or mountainous terrain. 0 Frequent trailer pulling.

Uses such as taxi, police, delivery or other commercial service.

If the vehicle is not used mainly under any of these conditions, change the fluid and filter every 30,000 miles (50 000 km). See “Automatic Transmission Fluid” in the Index for more information. Manual Transmission - Transrnission fluid does not require periodic changing.

7. FUEL FILTER REPLACEMENT* - Replace the fuel filter at the

specified interval or sooner if clogged.

8. SPARK PLUG REPLACEMENT*$ - Replace spark plugs with the type listed in Section 6. Spark plugs (AC908) for the 2.2L Engine (VIN Code 4) should be replaced every 100,000 miles (166 000 kilometers). Spark plugs (.CR43TSM) for the 4.3L engines (VIN Codes W and Z) should be replaced every 30,000 miles (50 000 kilometers). See ‘‘Specification Charts” in the Index.

9. SPARK PLUG WIRE INSPECTION* - Clean wires and inspect

for burns, cracks or other damage. Check the wire boot fit at the distributor and at the spark plugs. Replace wires as needed.

10. ENGINE TIMING CHECK AND DISTRIBUTOR CHECK*$ -

Adjust timing to underhood label specifications. Inspect the inside and outside of the distributor cap and rotor for cracks, carbon tracking and corrosion. Clean or replace as needed.

*An Emission Control Service

$=The California Air Resources Board has detennined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of vehicle usefui life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

7-8

?A fluid loss in these systems may indicate a problem. Have them inspected and repaired at once.

7-9

Owner Checks and Services Listed below are owner checks and services which would be made at the time period specified to help ensure proper safety, emission performance, and dependability of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in this section. At Least Once a Month Tire Inflation Pressure Check - Check the tires for proper inflation. If they are low, inflate them to the level specified on the Certification label. See “Inflation-Tire Pressure” in the Index. At feast Four Times a Year Tailgate Lubrication - Lubricate tailgate latch bolt, handle assembly pivot points, and hinges with lubricant recommended in this section. Lubricate every 3,000 miles (5 000 kilometers) if following Maintenance Schedule I, or every 7,500 &les (12 500 kilometers) if following Maintenance Schedule II. At Least Once a Year Key Lock Cylinder Lubrication - Lubricate key lock cylinders with one of the lubricants recammended in this section. Transmission Neutral or Clutch Start Switch Operation -

1. 2.

3. 4.

Before you start, be sure you have enough room around the vehicle. Firmly apply both the manual parking brake, and the regular brake. See “Brakes” and “Parking Brake” in the Index. Do not use the accelerator pedal. Be ready to turn off the engine immediately if it starts. On automatic transmission vehicles, try to start the engine in each gear. The starter should work only in T“ (Park) or “ N ’ (Neutral). On manual transmission vehicles, put the shift lever in “ N ’ (Neutral), push the clutch down halfway, and try to start the engine. The starter should work only when the clutch is pushed down all the way to the floor.

7-10

Steering Column Lock Operation - While parked, try to turn the key to LOCK in each gear shift position.

With an automatic transmission, the key should turn when the gear shift is in “P’ (Park).

to LOCK only

0 With manual shift, the key should turn to LOCK only wnen you’re in

“ R ’ (Reverse).

to LOCK without On vehicles with a key release lever, try to turn the key pressing the lever. The key should turn to LOCK only with the key lever depressed. On all vehicles, the key should come out only Parking ‘Brake and Transmission “ P ’ (Park) Mechanism Operation -

in LOCK.

Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular brake, set the manual parking brake.

To check the parking brake: With the engine running and the transmission in “N” (Neutral), slowly remove foot pressure from the regular brake pedal. Do this until the vehicle is held by the parking brake only. To check the “ P ’ (Park) mechanism’s holding ability: Apply the regular brake and shift to “P’ (Park). Release the manual parking brake, then slowly release the regular brake.

if the webbing has been cut or

Lap and Shoulder Belts Condition and Operation - Inspect belt system, including: webbjng, buckles, latch plates, retractors, guide loops and anchors. Have a belt assembly replaced otherwise damaged. Body Lubrication Service - Lubricate all body door hinges including the tailgate and tailgate handle pivot points. Lubricate the body hood, and rear compartment hinges, latches and locks including interior glove box and console doors, and any moving seat hardware. Lubricate the hood safety lever pivot and prop rod pivot. More frequent lubrication may be required when exposed to a corrosive environment.

fuel door

7-11

~

at

for proper

kate the steering linkage.

Periodic Maintenance Inspections Listed below are inspections and services which should be performed least twice a year (for instance, each spring and fall). You should let your GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary repairs are completed at once. Steering and Suspension Inspection? - Inspect front and rear suspension and steering system for damaged, loose or missing parts, signs of wear or lack of lubrication. Inspect power steering lines and hoses hook-up, binding, leaks, cracks, chafing, etc. Lu‘ Accelerator Control System - Lubricate all pivot points with engine oil, except the TBI throttle shaft. Do not lubricate the cam pulley. Remove all external deposits from pulley. Do not oil any accelerator or cruise control cables. Replace any cables that have high effort or excessive wear. Exhaust System Inspection - Inspect the complete system. Inspect the body near the exhaust system. Look for broken, damaged, missing or out-of-position parts, as well as open seams, holes, loose connections or other conditions which could cause a heat buildup in the floor pan or could let exhaust fumes seep into the passenger compartments. See “Engine Exhaust” in the Index. Drive Axle Service - Check readfront axle fluid level and add as needed. Check constant velocity joints and axle seals for leaking. Transfer Case (four-wheel drive) Inspection? - Every 12 months or at oil change intervals, check front axle and transfer case and add lubricant when necessary. Check vent hose at transfer case installation. More frequent lubrication may be required on off-road use.

for kinks and proper

?A fluid loss in these systems may indicate a problem. Have them inspected and repaired at once.

7- 12

Engine Coolant

Recommended Fluids & Lubricants NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM Dealer. FLUIDLUBRICANT USAGE API service SH or SG Energy Conserving I1 Engine Oil oils of the proper viscosity. The “SH” or “SG’designation may be shown alone or in combination with others, such as “SH/CD”, or “SH, SG, CD,” or “SGKD”, etc. To determine the preferred viscosity oil for your vehicle’s engine (e.g. SAE 5W-30). See “Engine Oil” in the Index. Mixture of water and a good quality ethylene glycol base antifreeze conforming to (4.3L) or GM-6043-M GM-6038-M Hydraulic Clutch Fluid (GM Part No. 12345347 or equivalent). Delco Supreme 11 brake fluid (GM Part No. 1052535 or DOT-3). GM Power Steering Fluid (GM Part No. 1050017) or equivalent conforming to GM spec 9985010. GM Lubricant (GM Part No. 1052182) or equivalent. DEXRON@-III (perferred) or DEXRON@-IIE Automatic Transmission Fluid.

Hydraulic Clutch System

Hydraulic Brake Systems

Automatic Transmission

Power Steering System

Manual Steering Gear

(2.2L)

Manual Iransrmssu a. 5-Speed (2.2L Engine)

b. 5-Speed (4.3L Engine)

No.

1052271).

Part

Differential: a. Standard - Front and a. Axle Rear b. Locking b.

Transfer Case

a. DEXRON@-IIE Automatic Transmission Fluid (GM Part No. 1051855). b. Synchromesh Transmission Fluid (GM Part No. 12345349).

SAE-8OW-90 GL-5

gear lubricant (GM

SAE-SOW-90 gear

lubricant (GM Part

No. 1052271). DEXRON@-IIE Automatic Transmission Fluid (GM Part No. 1051855).

7 -23

FLULD/LUIBRICANT

USAGE Column Shift, Transfer Chassis lubricant meeting requirements Case Shift Lever, Propeller NLGI Grade 2, Catagory LB or GC-LB Shaft Slip Splines and (GM Universal Joints. Clutch Linkage. Pushrod to Chassis lubricant meeting requirements of clutch fork joint.

NLGI Grade 2, Catagory LB or GC-LB (GM Part No. 1052497).

Part No. 1052497).

of

Hood Latch Assembly: a, Pivots and spring anchor b. Release Pawl

Front Wheel Bearings

Constant Velocity Universal Joint

Automatic Transmission Shift Linkage, Floor Shift Linkage, Hood and Door Hinges, Body Door Hinge Pins, Folding Seat, Fuel Door Hinge Key Lock Cylinders

Chassis Lubrication

Windshield Washer Solvent Weatherstrip

a. Engine oil (GM Part No. 1050109). b. Chassis lubricant meeting requirements of GM-6031-M (GM Part No. 1052497). Wheel bearing lubricant meeting requirements of NLG Grade 2, Catagory GC or GC-LB (GM Part No. 1051344). Chassis lubricant meeting requirements of NLG Grade 2, Catagory LB or GC-LB (GM Part No. 1052497). Engine oil (GM Part No. 1050109).

GM Multi-Purpose Lubricant (GM Part No. 12345 120) or a synthetic light weight engine oil (SAE 5W-30). Chassis lubricant meeting requirements of NLG Grade 2, Catagory LB or GC-LB (GM Part No. 1052497). GM Optikleen TM washer solvent (GM Part No. 1051515) or equivalent. Silicone grease (GM Part No. 1052863) or equivalent.

Tailgate Handle Pivot Multi-purpose lubricant meeting Points, Hinges, Latch Bolt, requirements of GM Part No. 9985164. and Linkage Gas Line Weather Strips

Gas Line De-Icer (GM Part No. 10515 16). Spray-A-Squeek (GM Part No. 1052277).

Maintenance Record After each of the preceding Scheduled Maintenance Services is performed, record the date, odometer reading, services performed (list item numbers) and who performed the services in the appropriate column. In addition, retain copies of your receipts. It is suggested that receipts be kept with your Owner’s Manual.

TO001

Service Station Checks It is important for you or a service station attendant to perform these under-hood checks at each fuel fill.

@ Check the engine oil level and add if necessary.

Check the engine coolant level and add if necessary.

0 Check the windshield washer fluid level and add if necessary.

See the Index under these items for information on how to check them.

,Battery The Delco Freedom battery needs no water. See Page 6-32.

,Cooling

Sysfem Check and add coolant only at the coolant recovery tank. See Page 6-23.

Engine Oil

\see Page 6-9m Transmission Fluid Automatic: See Page 6-15. Manual: See Page 6-18.

,Fuel

Capacity 20 U.S. Gal. (7.6L). Use unleaded gas only, 87 octane or higher. See Page 6-3.

Cold TiFe Pressure See Tire-Loading sticker on the inside of the rear edge of the driver's door lock pillar. See Page 6-45.

Hood Release Lever See Page 6-6. Remote Oil Filfer See Page 6-1 3. Windshield Washer Fluid See Page 6-28. Power Steering ' Reservoir See Page 6-26.

Clutch Fluid Reservoir See Page 6-20.

I c /

Brake Fluid. Reservoir See Page 6-29.

Spare Tire /

Pressure See Page 6-45.

fit-

7- 17

Notes

Customer Assistance Information

Program ................................................

Here you will find out how to contact Chevrolet if you need assistance . This section also tells you how to obtain service publications and how to report any safety defects . Customer Satisfaction Procedure ............................... 8-2 Customer Assistance for the Hearing or Speech Impaired (TDD) . . . . . 8-3 GM Participation in BBB AUTO LINE - Alternative Dispute Resolution 8-3 Reporting Safety Defects To The United States Government ......... 8-4 Reporting Safety Defects To The Canadian Government ............ 8-5 Reporting Safety Defects To General Motors ..................... 8-5 Roadside Assistance ......................................... 8-6 Courtesy Transportation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7 Service Publications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7

Customer Satisfaction Procedure Your satisfaction and goodwill are important to your dealer and Chevrolet. Normally, any concern with the sales transaction or the operation of your vehicle will be resolved by your dealer's Sales or Service Departments. Sometimes, however, despite the best intentions of all concerned, misunderstandings can occur. If your concern has not been resolved to your satisfaction, the following steps should be taken: STEP ONE - Discuss your concern with a member of dealership management. Normally, concerns can often be quickly resolved at that level. If the matter has already been reviewed with the Sales, Service, or Parts Manager, contact the owner of the dealership or the General Manager. STEP TWO - If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealership without further help, contact the Chevrolet Customer Assistance Center by calling 1-800-222-1020. Center in Oshawa by calling 1-800-263-3777 1-800-263-7854 In Mexico, call (525) 254-3777. In Puerto Rico or U.S. Virgin Islands, call 1-809-763-1315. In all other overseas locations, contact GM North American Export Sales in Canada by calling 1-41 6-644-41 12. As of October 4, 1993, call 1-905-6444112. For prompt assistance, please have the following information available to give the Customer Assistance Representative:

In Canada, contact GM of Canada Customer Assistance

(English) or

(French).

Your name, address, home and business telephone number

0 Vehicle Identification Number (This is available from the vehicle

of the instrument panel

registration or title, or the plate at the left top and visible through the windshield.) Dealership name and location Vehicle delivery date and present mileage Nature of concern

We encourage you to call the toll free number listed previously in order to give your inquiry prompt attention. However, if you wish to write Chevrolet, write to:

Chevrolet Motor Division Chevrolet Customer Assistance Center P. 0. Box 7047 Troy, MI 48007-7047

Refer to your Warranty and Owner Assistance Information booklet for addresses of Canadian and GM overseas offices.

. . .. .. .- I . .

8-2

When contacting Chevrolet, please remember that your concern will likely be resolved in the dealership, using the dealership’s facilities, equipment and personnel. That is why we suggest you follow Step One first if you have a concern. Customer Assistance for the Hearing or Speech Impaired (TDD) To assist customers who have hearing difficulties, Chevrolet has installed special TDD (Telecommunication Devices for the Deaf) equipment at its Customer Assistance Center. Any hearing or speech impaired customer who has access to a TDD or a conventional teletypewriter (TTY) can communicate with Chevrolet by dialing: 1-800-TDD-CHEV (1-800-833-2438).

(TDD users in Canada can dial 1-800-263-3830.)

GM Participation in 888 AUTO LlNE - Alternative Dispute Resolution Program* *This program may not be available in all states, depending on state law. Canadian owners refer to your Warranty and Owner Assistance information booklet. General Motors reserves the right to change eligibility limitations and/or to discontinue its participation in this program. Both Chevrolet and your Chevrolet dealer are committed to making sure you are completely satisfied with your new vehicle. Our experience has shown if a situation arises where you feel your concern has not been adequately addressed, that the Customer Satisfaction Procedure described earlier in this section is very successful. There may be instances where an impartial third-party can assist in arriving at a solution to a disagreement regarding vehicle repairs or interpretation of the New Vehicle Limited Warranty. To assist in resolving these disagreements Chevrolet voluntarily participates in BBB AUTO LINE. BBB AUTO LINE is an out-of-court program administered by the Better Business Bureau system to settle disputes between customers and automobile manufacturers. This program is available free of charge to customers who currently own or lease a GM vehicle. If you are not satisfied after following the Customer Satisfaction Procedure, you may contact the BBB using the toll-free telephone number, or write them at the following address:

BBB AUTO LINE Council of Better Business Bureaus 4200 Wilson Boulevard Suite 800 Arlington, VA 22203 Telephone: 1-800-955-5100

To file a claim, you will be asked to provide your name and address, your vehicle identification number (VIN), and a statement of the nature of your complaint. Eligibility is limited by vehicle age and mileage, and other factors. We prefer you utilize the customer satisfaction procedure before you resort to AUTO LINE, but you may contact the BBB at any time. The BBB will attempt to resolve the complaint serving as an intermediary between you and Chevrolet. If this mediation is unsuccessful, an informal hearing will be scheduled where eligible customers may present their case to an impartial third-party arbitrator. If you The arbitrator will make a decision which you may accept or reject. accept the decision, GM will be bound by that decision. The entire dispute resolution procedure should ordinarily take about forty days from the time you file a claim until a decision is made. Some state laws may require you to use this program before filing a claim with a state-run arbitration program or in the courts. For further information, contact the BBB at 1-800-955-5 100 or the Chevrolet Customer Assistance Center at 1-800-222-1020. REPORTING SAFETY DEFECTS TO THE UNITED STATES GOVERNMENT If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA), in addition to notifying General Motors. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or General Motors. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123

in the War- npton, D.C. area) or write to:

NHTSA, U.S. Department of Transportation Washington, D.C. 20590 You can also obtain other infon tion about motor vehicle safety from the Hotline.

REPORTING SAFETY DEFECTS TO THE CANADIAN GOVERNMENT If you live in Canada, and you believe that your vehicle has a safety defect, you should immediately notify Transport Canada, in addition to notifying General Motors of Canada Limited. You may write to:

Transport Canada, Box 8880 Ottawa, Ontario KlG 3J2 REPORTING SAFETY DEFECTS TO GENERAL MOTORS In addition to notifying NHTSA (or Transport Canada) in a situation like this, we certainly hope you’ll notify us. Please call us at 1-800-222-1020 , or write:

Chevrolet Motor Division Chevrolet Customer Assistance Center P. 0. Box 7047 Troy, MI 48007-7047 In Canada, please call us at 1-800-263-3777 (French). Or, write:

General Motors of Canada Limited Customer Assistance Center 1908 Colonel Sam Drive Oshawa, Ontario L1H 8P7

(English) or 1-800-263-7854

Chevrolet Rc rdside Assistance Program To enhance Chevrolet’s strong commitment to customer satisfaction, Chevrolet is excited to provide the services of the ChevroletIGeo Roadside Assistance Center. q-Hour Roadside Assistance Number Koadside Assistance is available 24 hours a day, 365 days a year, by calling 1-800-CHEV USA (1-800-243-8872). This toll-free number will provide you over-the-phone roadside assistance with minor mechanical problems. If your problem cannot be resolved over the phone, our advisors have access to a nationwide network of dealer recommended service providers. The following services are available:

. -

; L

. I

- -

0 Towing 0 Locksmith Tire repair

0 Rental car or taxi

Additional services as necessary

The Roadside Assistance Center uses companies that will provide you with quality and priority service. When roadside services are required, our advisors will explain any payment obligations that may utilizing outside services. For prompt assistance when calling, please have the following available to give to the advisor:

be incurred for

0 Vehicle Identification Number

License plate number

0 Vehicle color 0 Vehicle location 0 Telephone number where you can be reached

Vehicle mileage

0 Description of problem Canadian Roadside Assistance Vehicles purchased in Canada have an extensive Roadside Assistance program accessible from anywhere in Canada or the U.S.A. Please refer to the separate brochure provided by the dealer or call 1-800-268-6800 emergency services.

for

8-6

Courtesy Transportation

Chevrolet/Geo offers Courtesy Transportation for customers needing warranty service. Courtesy Transportation will be offered in conjunction with the coverage provided by the BUMPER TO BUMPER New Vehicle Limited Warranty to Chevrolet/Geo passenger car and light duty trucks. In Canada, please consult your GM Dealer for information on courtesy transportation.

retail purchasers of 1994

COURTESY TRANSPORTATION INCLUDES:

One way SHUTTLE RIDE for any warranty repair. Up to $30 maximum daily VEHICLE RENTAL allowance for any overnight warranty repair up to 5 days. Up to $30 maximum daily CAB, BUS, or OTHER transportation allowance in lieu of rental for any overnight warranty repair up to 5 days. Up to $10 daily FUEL allowance for rides provided by another person (i.e., friend, neighbor, etc.) in lieu of rental for any overnight warranty repair up to 5 days.

Note: All Courtesy Transportati---~ arrang by your ChevroletIGeo dealershlp service management. Claim amounts should reflect all actual costs.

Its will be administered

Chevrolet/Geo Courtesy Transportation Program is not part of the BUMPER TO BUMPER New Vehicle Limited Warranty. Chevrolet/Geo reserves the right to make any changes or discontinue the Courtesy Transportation Program at any time without notification. For additional program details, contact your Chevrolet/Geo dealer.

Service Publications Information on how to obtain Product Service Publications (PSP's) and Indexes as described below is applicable only in the fifty U.S. states (and the District of Columbia) and only for cars and light trucks with GVWR less than 10,000 pounds (4 536 kg). In Canada, information pertaining to Product Service Bulletins and Indexes can be obtained by writing to:

General Motors of Canada Limited Service Publications Department 1908 Colonel Sam Dr. Oshawa, Ontario L1H 8P7 Chevrolet regularly sends its dealers useful service bulletins about Chevrolet products. Chevrolet monitors product performance in the field. We then prepare bulletins for servicing our products better. Now, you can get these bulletins too.

8-7

of Bulletins cover various subjects. Some pertain to the proper use and care your vehicle. Some describe costly repairs, Others describe inexpensive repairs which, if done on time with the latest parts, may avoid future costly repairs. Some bulletins tell a technician how to repair a new or unexpected condition. Others describe a quicker way to fix your vehicle. They can help a technician service your vehicle better. Most bulletins apply to conditions affecting a small number of cars or trucks. Your Chevrolet dealer or a qualified technician may have to determine if a specific bulletin applies to your vehicle. You can subscribe to all Chevrolet’s bulletins by calling Helm, Inc. at 1-800-782-4356. This way you’ll get them as they become available. mdividual PSP’s li you don’t want to buy all the PSP’s issued by Chevrolet truck models in the model year, you can buy individual PSP’s, such as those which may pertain to a particular model. To do this, you will first need to see our index of PSP’s. It provides a variety of information. Here’s what you’ll find in the index and how you can get one: What You’ll Find in the Index:

for au car67

A list of PSP’s published by Chevrolet in a model year (1990 or later). PSP’s covering all models of Chevrolet cars or light trucks (less than 10,000 pounds (4 536 kg) GVWR) are listed in the same index. Ordering information so you can buy the specific PSP’s you may want. Price information for the PSP’s you may want to buy.

How You Can Get an Index: Indexes are published periodically. Most of the PSP’s which could potentially apply to the most recent Chevrolet models will be listed in the most recent publication for that model year. This means you may want to wait until the end of the model year before ordering an index, if you are interested in buying PSP’s pertaining Some PSP’s pertaining to a particular model year vehicle may be published in later years, and these would be listed order an index for a model year that is not over yet, we’ll send you the most recently published~issue. Check the ordering form for indexes for earlier model years. Cut out the ordering form, fill it out, and mail it in. We will then see to it that an index is mailed to you. There is no charge for indexes for the 1989-1994 model years.

to a current model year car or truck.

in the later year’s index. When you

8-8-

Toll-Free Telephone Number If you want an additional ordering form for an index, just call toll-free and we’ll be happy to send you one. Automated recording equipment will take your name and mailing address. The number to call is 1-800-55 1-4123.

Copies at Participating Dealers Copies of Indexes and individual PSP’s are at your participating Chevrolet dealer. You can ask to see them. A VERY IMPORTANT REMINDER: These PSP’s are meant for technicians. They are not meant for the “do-it-yourselfer.” Technicians have the equipment, tools, safety instructions, and know-how to do a job quickly and safely. Chevrolet reserves the right to change these procedures without notice.

Chevrolet Service Publications You can get these Product Service Publications by using the order form. You can also get Service Manuals and Owner Publications.

8-9

! , '!

8-10

n

Index

3 4 3-5 6-78 3-5 3-22

2-51 6-14 3-4. 6-42

Accessory rower Outlets .......................................... Aircleaner ..................................................... Airconditioning ............................................ Fanswitch ................................................... Functionhob ................................................ Refrigerantcapacity ........................................... ............................................. Temperature Knob Antenna. FixedMast ............................................. Anti-lock Brakes (See “Brakes”) Appearancecare ................................................ 6-59 Materials Chart ............................................... 6-67 Arbitration Program ............................................... 8-3 Audiosystems ................................................... 3-5 AMRadio .................................................... 3-6 AM-FM Stereo Audio Compact Disc (CD) System . . . . . . . . . . . . . . . . . . . 3-17 AM-FM Stereo Audio System .................................... 3-8 AM-FM Stereo Audio System with Cassette Deck . . . . . . . . . . . . . . . . . . . 3-10 AM-FM Stereo Audio System with Cassette Deck and Equalizer . . . . . . . . 3-13 Anti-Theft System (CD) System) ................................. 3-20 Cassette Tape Player Care ....................................... 3-16 CompactDiscCare ............................................ 3-22 .......................................... 2-16 ....................................................... Fluid 6-15 Front ....................................................... Rear ........................................................ RearLocking .................................................

Automatic Transmission

6-22 6-20 2-21

Axle

Battery ........................................................ Belts (See “Safety Belts”) Better Business Bureau Mediation .................................... Blizzard ....................................................... Brakes Adjustment ................................................... .................................................... Anti-lock Anti-lock Warning Light ....................................... Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .......................................... Four-wheel Anti-lock .......................................... Rear-Wheel Anti-lock Leakcheck .................................................. Mastercylinder .............................................. Paking ..................................................... .................................................. Pedal Travel RearDrumBrakes .............................................. Replacingparts ............................................... System Warning Light ..................................... 2.59. Trailer ...................................................... Wear Indicators ................................................

6-32

8-3 4-35

4-5 4-6 2-60 6-30 4-7 4-7 6-28 6-29 2-16 4-7 4-7 6-32 4-5 4 4 4 4-6

Brakes (continued) Braking ......................................................... InEmergencies ................................................ ............................................ Break.In. New Vehicle Bulb Replacement ............................................... Replacement Chart ............................................

4-5 4-8 2-9 6-33 6-78

Capacities and Specification Charts .................................. CarbonMonoxide .......................................... 2.25, 2.26 Cassette Tape Player (see “Audio Systems” ) .............................................. Catalytic Converter Certif“lcation/Tire Label ........................................... Changing a Flat Tire ....... ...................................... Chemical Paint Spotting ........................................... Child Restraints (See “Safety Belts”) CHMSLFeedWire .............................................. Cigarette LightedAshtray ......................................... Circuit Breakers (See “Fuses”) Cleaning

6-73

6-44 6-52

.5.20.

6-67

2-67 2-52

Finishcare .................................................. 6-65 Glass ....................................................... 6-64 Inside of Vehicle .............................................. 6-60 Instrument Panel. Top .......................................... 6-63 Outside of Vehicle ............................................. 6-64 Special Problems ......................................... 6-62. 6-66 .............................................. Vinyl or Leather 6-63 Wheels and Tires .............................................. 6-65 Windshield .................................................. 6-64 Clock .......................................................... 3-8 AMRadio .................................................... 3-7 AM-FM Stereo Audio Compact Disc (CD) System ................... 3-17 AM-FM Stereo Audio System .................................... 3-8 AM-FM Stereo Audio System with Cassette Deck . . . . . . . . . . . . . . . . . . . 3-10 AM-FM Stereo Audio System with Cassette Deck and Equalizer . . . . . . . . 3-13 3-2 6-50

Comfort Controls ................................................. Conversion to Chassis Cab ........................................ Coolant (See “Engine”) Cooling System Capacity .......................................... 6-73 Crankcase Capacity .............................................. 6-74 CruiseControl .................................................. 2-39 Increasespeed ............................................... 2-42 OnHills ..................................................... 2-43 Passing ..................................................... 2-43 Reducespeed ................................................ 2-43 Resume ..................................................... 2-41 Set .......................................................... 2-40 ToGetOutOf ................................................ 2-44 Customer Assistance for the Hearing or Speech Impaired . . . . . . . . . . . . . . . . . 8-3 Customer Satisfaction Procedure ..................................... 8-2

.........................

Indicator Light

.....................................

247. 2-64 2-47.2-62. 2-64 2-48 2-5 2-6

Daytime Running Lights (Canada Only) DomeLight .................................................... Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Locks ........................................................ Driving Across an Incline ............................................. 4-22 ........................................ After Off-Road Driving 4-25 AtNight .................................................... 4-25 Backingup .................................................. 4-42 Defensive .................................................... 4-2 Downhill ...................................................... 4-20 Freeway . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-29 Highway Hypnosis ............................................ 4-31 Hydroplaning ................................................ 4-27 InBlizzard ................................................... 4-33 InCity ...................................................... 4-28 In Mud. Sand. Snow. Or Ice ................................ 4-23. 5-35 InRain ...................................................... 4-26 InWater ..................................................... 4-24 LossofControl ............................................... 4-12 Nightvision ................................................. 4-26 Off-Roading ................................................. 4-13 OnCurves ................................................... 4-18 OnGrades ................................................... 4-43 .................................... On Hill and Mountain Roads 4-31 On Off-Road Hills ............................................ 4-17 OnSnoworIce ............................................... 4-33 Passing ..................................................... 4-11 Skidding .................................................... 4-12 Stuck in Deep Snow ........................................... 5-35 Throughwater .......................................... Uphill ...................................................... 4-18 Winter ...................................................... 4-33 WithaTrailer ................................................ 4-38 DrunkenDriving ................................................. 4-2

2-14. 4-24

Electrical System

Engine

....................................... ...........................................

Accessory Power Outlets Add-on Equipment Adding Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Aircleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Coolant (Block) Heater ................................ 2.14.3-5. 6.13 Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.23. 6.73 Coolant Temperature Gage ...................................... Crankcase ................................................... Exhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . FanNoise ................................................... Identification ............................................ Oil (See “Oil”)

2-51 6-70

5-15, 6-25 6-14

2-60 6-74 2-25 5-19

6-69, 6-73

Engine (continued)

Overheating .................................................. Runningwhileparked ......................................... Starting ..................................................... Equipment, Add-on Exhaustsystem .................................................

5-12 2-16 2-12 ............................................. 6-47 6-44

Gages ......................................................... 2-58 Coolant Temperature Gage ...................................... 2-60 ................................................... 2-66 Fuel Gage Odometer .............................................. 2-56, 2-57 Oil Pressure Gage ............................................. 2-62 ..-.............. 2-56 Speedometer ................................ Tachometer .................................................. 2-57 Trip Odometer ................................................ 2-57 Voltmeter .................................................... 2-67

Gages (continued)

If You’re Stuck in Sand. Mud. Ice. or Snow ........................... Ignitionswitch .................................................. Inflation-Tire Pressure ............................................

5-35 2-10 6-52

Jackstorage ............................................... Jump Starting ................................................

5-21, 5-29 5-3’5-4

Key Release Lever ................................................ Keys ...........................................................

2-11 2-3

L

Labels

6-45. 6.52

6-48 Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-45

CertificatiodI‘ire ......................................... Truck-Camper ............................................... Brake System Warning .................................... Bulb Replacement ........................................ Charging System Light ......................................... CheckGagesLight ............................................ Dome ....................................................... FogLamps .................................................. Front ParkingEurn Signal ....................................... Headlights (See “Headlights”) InQcator ............................................... 2.62. 2.65 Malfunction Indicator ..................................... 2.61. Operation ................................................... ServiceEngineSoon ........................................... Rear ................................................... Replacement Chart ............................................

2-63 2-63 2-48 2-46 6-36

6-44 2-35 6-44

2.59. 4-16 6.33. 6-74

.......................................

Loading Information ................................... Loading Your Vehicle Lubrication ..................................................... Accelerator Control System ..................................... Body ....................................................... FrontAxle ................................................... Front Suspension and Steering Linkage ............................ ......................... Front Wheel Bearings (Two-Wheel Drive) TailgateHandle ............................................... HoodLatchesandHinge ........................................ Lock Cylinders ............................................... Propeller Shaft Slip SplinesNniversal Joints ........................ RearAxle ................................................... RecommendedLubricants ...................................... ................................................ Transfer Case

6-43 6-43 6-43 6-22 6-39 6-39 6-36 6-34 6-44 6-43 6-20 7-13 6-21

6-37, 6-74 6-74 4-14,645, 6-48 4-14, 6-38

Maintenance

OtherItems .................................................. ........................................... Periodic Inspections Record ...................................................... ScheduledMaintenance ......................................... Underbody .................................................. WhenTowingaTrailer ......................................... Master Cylinder (See “Brakes”) Mirrors ........................................................ Convexoutside ............................................... Inside ....................................................... Outside ..................................................... Vanity ......................................................

ModelReference ..................................................

6-39 7-12 7-16 7-3 6-67 4-38

2-48 2-50 2-48 2-49 2-50 ... 111

0

Odometer ................................... ............. 2.56. 2.57 Off-Road Driving (See “Driving”) Off-RoadRecovery .............................................. Oil ............................................................ Additives .................................................... DisposalofUsed .............................................. Pressure Gage ................................................ ToCheck ..................................................... WhatKindtoUse ............................................. WhentoAdd .................................................. Whentochange .............................................. Owner Checks and Services ........................................

Parking

.................................................... On Hills Over Things That Burn ......................................... Torque Lock (Automatic Transmission) ............................ Your Vehicle (Manual Transmission) .............................. ParkingBrake .............................................. 2.21, 2.28 Passing Other Vehicles ............................................ Payload Capacity ................................................ Periodic Maintenance Inspections ................................... Power DoorLocks ................................................... Steering ...................................................... SteeringFluid ................................................ Winches ..................................................... Product Service Publications ........................................

4-10 6-9 6-13 6-13 2-62 6-9 6-10 6-9 6-13 7-10

4-43 2-24 2-24 2-24

4-11 6-47 7-12

2-7 4-8 6-26 4-45 8-7

Pressure

...... Radiator Radio (see “Audio Systems”) ................................ 7-13 Recommended Fluids and Lubricants RecoveryHooks ................................................. 5-35 Replacement Parts ............................................... 6-73 Reporting Safety Defects ........................................... 8-4 Roadside Assistance ............................................... 8-5 ............................................ 5-35 Rocking Your Vehicle

6-25

Safety Belts

Cleaning .................................................... 6-63 Checking Restraint System ...................................... 1-33 ChildRestraints ............................................... 1-25 Children .................................................... 1-23 Small Children and Babies ...................................... 1-23 Extender .................................................... 1-33 Lap ........................................................ 1-20 Lapshoulder ................................................. 1-13

T

Tachometer ..................................................... 2-57 Tailgate ......................................................... 2-7 Theft ....................................................... 2 4 2 - 8 Thermostat ..................................................... 6-26 TjiltWheel ...................................................... 2-33 Tires .......................................................... 6-51 Balancing ...................................................... 6-57 Chains ...................................................... 6-59 ChangingaFlat .......................................... 5-20, 5-26 Flat ........................................................ 5-20

V

Vehicle

Damage Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . vii Identification Number .......................................... 6-69 Loading ..................................................... 6-45 Storage ..................................................... 6-32 . . . . . . Symbols .............................................. vn. ~111. IX. x Ventilation System ................................................ 3-2 AirVents ..................................................... 3-3 Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2 Voltmeter ...................................................... 2-67

W

10

Notes

Notes

.C - 9408

WE SUPPORT

VOLUNTARY TECHNICIAN CERTIFICATION THROUGH

National Institute for

AUTOMOTIVE

SERVICE

EXCELLENCE

GM -