1997 Chevrolet Corvette Owners Manual

7-20

Part B: Owner Checks and Services Part C: Periodic Maintenance Inspections Part D: Recommended Fluids and Lubricants Part E: Maintenance Record

7-1

IMPORTANT: KEEP ENGINE OIL AT THE PROPER RECOMMENDED

LEVEL AND CHANGE AS I

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to keep your vehicle in good condition, please maintain your vehicle properly.

Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or your Corvette dealer for details.

How This Section is Organized The remainder of this section is divided into five parts: “Part A: Scheduled Maintenance Services” shows what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools an& equipment for the job. If you have any doubt, have a qualified technician do the work.

If you are skilled enough to do some work on your vehicle, you will probably want to get the service

information GM publishes. See “Service and Owner Publications” in the Index. “Part B: Owner Checks and Services” tells you what should be checked and when. It also explains what you can easily do to help keep your vehicle in good condition. “Part C : Periodic Maintenance Inspections” explains important inspections that your Chevrolet dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants” lists some products GM recommends to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record” provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this part. This will help you determine when your next maintenance should be done. In addition, it is a good idea to keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

7-3

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you’ll find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your Chevrolet dealer.

This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts. The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. This schedule is for vehicles that: 0 carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index.

0 are driven on reasonable road surfaces within legal

driving limits.

0 use the recommended fuel. See “Fuel” in the Index.

7-4

Maintenance Schedule

The services shown in this schedule up to 100,000 miles (160 000 km) should be performed after 100,000 miles (160 000 km) at the same intervals. The services shown at 150,000 miles (240 000 km) should be performed at the same interval after 150,000 miles (240 000 km). See “Owner Checks and Services” and “Periodic Maintenance Inspections” following. Footnotes f The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emissions warranty or limit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

* Your Corvette has an Engine Oil Life Monitor. This monitor will show you when to change the oil -- usually between 3,000 miles (5 000 km) and 10,000 miles (1 6 000 km) since your last oil change. Under severe conditions, the indicator may come on before 3,000 miles (5 000 km). Never drive your vehicle more than 10,000 miles (16 000 km) or 12 months without an oil change. Use engine oil meeting the GM Standard GM47 18M. The Engine Oil Life Monitor won’t detect dust in the oil. So if you drive in a dusty area, be sure to change your oil every 3,000 miles (5 000 km) or sooner if the CHANGE OIL light comes on. Remember to reset the Oil Life Monitor when the oil has been changed. For more information, see “Engine Oil Life Monitor” in the Index.

7-5

I Maintenance Schedule 10,000 Miles (1 6 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.) Inspect air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote T.)

20,000 Miles (32 000 km) 17 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.) Inspect air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Sewice. (See footnote “f)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

I Maintenance Schedule 1 30,000 Miles (48 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.) Replace air cleaner filter. An Emission Control Service. Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

40,000 Miles (64 000 km) Cl Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.)

0 Inspect air cleaner filter if you are

driving in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote “f)

DATE

ACTUAL

MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE SERVICED

BY:

7-7

Maintenance Schedule 50,000 Miles (80 000 km)

Check the Engine Oil Life Monitor. If engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.) 0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote y.)

0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32°C) or higher.

- In hilly or mountainous terrain. - Uses such as high performance operation. v y o u do not use your vehicle under any of these conditions, the fluid and filter do not require change. Manual transmissiorz fluid doesn ’t require change.

I DATE

ACTUAL

MILEAGE

SERVICED

B Y

I Maintenance Schedule I 60,000 Miles (96 000 km)

Check the Engine Oil Life Monitor. If engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.)

0 Replace air cleaner filter.

An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.) 0 Inspect engine accessory drive belt.

An Emission Control Service.

I DATE

I ACTUAL MILEAGE

ISERVICED

BY:(

7-9

I

Maintenance Schedule 70,000 Miles (112 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.) Cl Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote “f.)

DATE ACTUAL MILEAGE + SERVICED BY:

I DATE

80,000 Miles (128 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.)

0 Inspect air cleaner filter if you are

driving in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote T.)

ACTUAL

MILEAGE

SERVICED

BY:

7-10

* ---:

. .

I

I Maintenance Schedule 90,000 Miles (144 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote *.)

0 Replace air cleaner filter. An Emission Control Service. Cl Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

100,000 Miles (1 60 000 km) 0 Check the Engine Oil Life Monitor. If

engine oil and filter are changed, reset the Engine Oil Life Monitor. See “Engine Oil” in the Index. An Emission Control Service. (See footnote * .)

Cl Inspect air cleaner filter if you are

driving in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote T.)

0 Replace spark plugs. An Emission Control Service. 0 Inspect spark plug wires. An Emission Control Service.

DATE SERVICED

ACTUAL MILEAGE

B Y

(Continued) n 4 4 ’ / -11

Maintenance Schedule

100,000 Miles (160 000 km) (Continued)

Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32°C) or higher.

- In hilly or mountainous terrain. - Uses such as high performance operation. If you haven ’t used your vehicle under any of these conditions, the fluid and filter do not require change. Manual transmission fluid doesn ’t require change.

DATE SERVICED

ACTUAL MILEAGE

BY:

7-12

150,000 Miles (240 000 km) Cl Drain, flush and refill the cooling system

(or every 60 months since last service, whichever occurs first). See “Engine Coolant’’ in the Index for what to use. An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

- I

Windshield Washer Fluid Level Check Check the windshield washer fluid level in the windshield washer tank and add the proper fluid if necessary. See “Windshield Washer Fluid” in the Index for further details. At Least Once a Month Tire Inflation Check Make sure tires are inflated to the correct pressures. See “Tires” in the Index for further details.

Cassette Deck Service Clean cassette deck. Cleaning should be done every 50 hours of tape play. See “Audio Systems” in the Index for further details.

Part B: Owner Checks and Services Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Part D. At Each Fuel Fill It is important for you or a service station attendant to per$orm these underhood checks at each fuel fill.

Engine Oil Level Check Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for further details.

Engine Coolant Level Check Check the engine coolant level and add DEX-COOL@ coolant mixture if necessary. See “Engine Coolant” in the Index for further details.

7-13

At Least *ice a Year Restraint System Check Make sure the safety belt reminder light and all your belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged safety belt system parts. If you see anything that might keep a safety belt system from doing its job, have it repaired. Have any torn or frayed safety belts replaced. Also look for any opened or broken air bag coverings, and have them repaired or replaced. (The air bag system does not need regular maintenance.)

Wiper Blade Check Inspect wiper blades for wear or cracking. Replace blade inserts that appear worn or damaged or that streak or miss areas of the windshield. Also see “Wiper Blades, Cleaning’’ in the Index.

Manual Transmission Check Check the transmission fluid level; add if needed. See “Manual Transmission” in the Index. Check for leaks. A fluid loss may indicate a problem. Have the system inspected and repaired if needed.

Automatic Transmission Inspection It is not necessary to check the transmission fluid level. A transmission fluid leak is the only reason for fluid loss. Check for leaks. If a leak occurs, take the vehicle to your Chevrolet dealership Service Department and have it repaired as soon as possible. At Least Once a Year Key Lock Cylinders Service Lubricate the key lock cylinders with the lubricant specified in Part D.

Body Lubrication Service Lubricate all body door hinges. Also lubricate all hinges and latches, including those for the hood, rear compartment, console door and any folding seat hardware. Part D tells you what to use. More frequent lubrication may be required when exposed to a corrosive environment.

Starter Switch Check

When you are doing this check, the vehicle could move suddenly. If it does, you or others could be injured. Follow the steps below.

1. Before you start, be sure you have enough room

around the vehicle.

2. Firmly apply both the parking brake (see “Parking

Brake” in the Index if necessary) and the regular brake. NOTE: Do not use the accelerator pedal, and be ready to turn off the engine immediately if it starts. 3. On automatic transmission vehicles, try to start the engine in each gear. The starter should work only in PARK (P) or NEUTRAL (N). If the starter works in any other position, your vehicle needs service. On manual transmission vehicles, put the shift lever in NEUTRAL (N), push the clutch down halfway and try to start the engine. The starter should work only when the clutch is pushed down all the way to the floor. If the starter works when the clutch isn’t pushed all the way down, your vehicle needs service.

Brake-Transmission Shift Interlock (BTSI) Check (Automatic Transmission)

A CAUTION:

When you are doing this check, the vehicle could move suddenly. If it does, you or others could be injured. Follow the steps below.

1.

2.

3.

Before you start, be sure you have enough room around the vehicle. It should be parked on a level surface. Firmly apply the parking brake (see “Parking Brake” in the Index if necessary). NOTE: Be ready to apply the regular brake immediately if the vehicle begins to move. With the engine off, turn the key to the ON position, but don’t start the engine. Without applying the regular brake, try to move the shift lever out of PARK (P) with normal effort. If the shift lever moves out of PARK (P), your vehicle’s BTSI needs service.

7-15

Ignition Automatic Transmission Lock Check While parked, and with the parking brake set, try to turn the ignition key to OFF in each shift lever position. The key should turn to OFF only when the shift lever is in PARK (P). On all vehicles, the key should come out only in OFF.

Parking Brake and Automatic Transmission PP-K(P)”

.mCt k

A CAUTION:

When you are doing this check, your vehicle could begin to move. You or others could be injured and property could be damaged. Make sure there is room in front of your vehicle in case it begins to roll. Be ready to apply the regular brake at once should the vehicle begin to move.

Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular brake, set the parking brake.

To check the parking brake’s holding ability: With the engine running and transmission in NEUTRAL (N), slowly remove foot pressure from the regular brake pedal. Do this until the vehicle is held by the parking brake only. To check the PARK (P) mechanism’s holding ability: With the engine running, shift to PARK (P). Then release all brakes.

Underbody Flushing Service At least every spring, use plain water to flush any corrosive materials from the underbody. Take care to clean thoroughly any areas where mud and other debris can collect.

Part C: Periodic Maintenance Inspections Listed below are inspections and services which should be performed at least twice a year (for instance, each spring and fall). You should let your GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary repairs are completed at once. Proper procedures to perform these services may be found in a GM service manual. See “Service and Owner Publications’’ in the Index. Steering and Suspension Inspection Inspect the front and rear suspension and steering system for damaged, loose or missing parts, signs of wear or lack of lubrication. Inspect the power steering lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Tire and Wheel Inspection Inspect the tires for uneven wear or damage. If there is irregular or premature wear, check the wheel alignment. Inspect for damaged wheels.

Exhaust System Inspection Inspect the complete exhaust system. Inspect the body near the exhaust system. Look for broken, damaged, missing or out-of-position parts as well as open seams, holes, loose connections or other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes into the vehicle. See “Engine Exhaust” in the Index. Radiator and Heater Hose Inspection Inspect the hoses and have them replaced if they are cracked, swollen or deteriorated. Inspect all pipes, fittings and clamps; replace as needed. Rear Axle Service Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index. A fluid loss may indicate a problem. Check the axle and repair Brake System Inspection Inspect the complete system. Inspect brake lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Inspect other brake parts, including calipers, parking brake, etc. You may need to have your brakes inspected more often if your driving habits or conditions result in frequent braking.

it if needed.

Part D: Recommended Fluids and Lubricants NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.

USAGE Engine Coolant

USAGE Engine Oil

FLUIDLUBRICANT The engine requires a special oil meeting GM Standard GM47 18M. Oils meeting this Standard may be identified as synthetic, and should also be identified with the American Petroleum Institute Certified For Gasoline Engines “Starburst” symbol. However, not all Synthetic API oils with the Starburst symbol will meet this GM Standard. You should look for and use only an oil that meets GM Standard GM4718M. For the proper viscosity, see “Engine Oil” in the Index.

Hydraulic Brake System

Hydraulic Clutch System

Power Steering System

Manual Transmission Automatic Transmission

Brake Fluid

FLUID/LUBRICANT 50/50 mixture of clean water (preferably distilled) and use only GM Goodwrench@ DEX-COOL TM or Havoline@ DEX-COOL coolant. See “Engine Coolant” in the Index. Delco Supreme 11 (GM Part No. 12377967 or equivalent DOT-3 brake fluid). Hydraulic Clutch Fluid (GM Part No. 12345347 or equivalent DOT-3 brake fluid). GM Synthetic Power Steering Fluid (GM Part No. 12345866 or 12345867 or equivalent). DEXRON@-I11 Automatic Transmission Fluid. DEXRON@-I11 Automatic Transmission Fluid.

USAGE Key Lock Cylinders

Rear Axle (Limited-Slip Differential)

Windshield Washer Solvent

(GM Part

FLUIDLUBRICANT Multi-Pur ose lubricant, Superlube No. 12346241 or equivalent). Axle Lubricant (GM Part No. 12345977) and 4 ounces (1 18 ml) of Limited-Slip Differential Lubricant Additive (GM Part No. 1052358 or equivalent) where required. See “Rear Axle” in the Index. GM Optikleen@ Washer Solvent (GM Part No. 105 15 15) or equivalent.

I USAGE

Hood Latch Assembly, Pivots, Spring Anchor and Release Pawl Hood and Door Hinges

Weatherstrip Conditioning

FLUIDLUBRICANT Lubriplate lubricant aerosol (GM Part No. 12346293 or equivalent) or lubricant meeting requirements of NLGI ## 2, Category LB or GC-LB. Multi-purpose lubricant, Superlube@ (GM Part No. 12346241 or equivalent). Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).

See “Replacement Parts” in the Index for recommended replacement filters and spark plugs.

7-19

Part E: Maintenance Record I date, odometer reading and who performed the service After the scheduled services are performed, record the

in the boxes provided after the maintenance interval.

Any additional information from “Owner Checks and Services” or “Periodic Maintenance” can be added on the following record pages. Also, you should retain all maintenance receipts. Your owner information portfolio is a convenient place to store them.

Maintenance Record

Maintenance Record

DATE

ODOMETER READING

BY

MAINTENANCE PERFORMED SERVICED

Maintenance Record

MAINTENANCE

PERFORMED

READING DATE

SERVICED

ODOMETER

BY

7-22

&& Section 8 Customer Assistance Information

Here you will find out how to contact Chevrolet if you need assistance. This section also tells you how to obtain service publications and how to report any safety defects.

8-2 8-4

8-5 8-7 8-8 8-9

Customer Satisfaction Procedure Customer Assistance for Text Telephone (TTY) Users Chevrolet/Geo Roadside Assistance Program Canadian Roadside Assistance Courtesy Transportation GM Participation in an Alternative Dispute Resolution Program

8- 10 8- 10

8-11

8-11 8-11

Warranty Information Reporting Safety Defects to the United States Government Reporting Safety Defects to the Canadian Government Reporting Safety Defects to General Motors Ordering Service and Owner Publications in Canada

8-1

Chevrolet dealers have the facilities, trained technicians and up-to-date information to promptly address any concerns you may have. However, if a concern has not been resolved to your complete satisfaction, take the following steps: STEP ONE -- Discuss your concern with a member of dealership management. Normally, concerns can be quickly resolved at that level. If the matter has already been reviewed with the Sales, Service or Parts Manager, contact the owner of the dealership or the General Manager.

8-2

STEP TWO -- If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealership without further help, contact the Chevrolet Customer Assistance Center by calling 1-800-222- 1020. In Canada, contact GM of Canada Customer Communication Centre in Oshawa by calling 1-800-263-3777 (English) or 1-800-263-7854 (French). For help outside of the United States and Canada, call the following numbers as appropriate:

In Mexico: (525) 625-3256 In Puerto Rico: 1-800-496-9992 (English) or 1-800-496-9993 (Spanish)

In the U S . Virgin Islands: 1-800-496-9994 In the Dominican Republic: 1-800-75 1-4135 (English) or 1-800-75 1-4136 (Spanish) In the Bahamas: 1-800-389-0009 In Bermuda, Barbados, Antigua and the British Virgin Islands: 1-800-534-0122 In all other Caribbean countries: (809) 763- 13 15 In other overseas locations, call GM International Product Center in Canada at: (905) 644-41 12.

8-3

Refer to your Warranty and Owner Assistance Information booklet for addresses of GM Overseas offices. When contacting Chevrolet, please remember that your concern will likely be resolved in the dealership, using the dealer’s facilities, equipment and personnel. That is why we suggest you follow Step One first if you have a concern. Customer Assistance for Text Telephone (TTY) Users To assist customers who are deaf, hard of hearing, or speech-impaired and who use Text Telephones (TTYs), Chevrolet has TTY equipment available at its Customer Assistance Center. Any TTY user can communicate with Chevrolet by dialing: 1-800-833-CHEV. (TTY users in Canada can dial 1-800-263-3830.)

For prompt assistance, please have the following information available to give the Customer Assistance Representative:

Your name, address, home and business telephone numbers Vehicle Identification Number (This is available from the vehicle registration or title, or the plate at the top left of the instrument panel and visible through the windshield.) Dealership name and location Vehicle delivery date and present mileage Nature of concern

We encourage you to call us so we can give your inquiry prompt attention. However, if you wish to write Chevrolet, address your inquiry to:

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 7047 Troy, MI 48007-7047

In Canada, write to:

General Motors of Canada Limited Customer Communication Centre, 163-005 1908 Colonel Sam Drive Oshawa, Ontario L1H 8P7

8-4

ChevroletIGeo Roadside Assistance Program

To enhance Chevrolet’s strong commitment to customer satisfaction, Chevrolet is excited to announce the establishment of the Chevrolet/Geo Roadside Assistance Center. As the owner of a 1997 ChevroletlGeo, membership in Roadside Assistance is free.

Roadside Assistance is available 24 hours a day, 365 days a year, by calling 1-800-CHEV-USA (1 -800-243-8872). This toll-free number will provide you over-the-phone roadside assistance with minor mechanical problems. If your problem cannot be resolved over the phone, our advisors have access to a nationwide network of dealer recommended service providers. Roadside membership is free, however some services may incur costs. Roadside offers two levels of service to the customer, Basic Care and Courtesy’” Care:

Toll-free number, 1 -800-CHEV-USA

0 Free towing for warranty repairs 0 Basic over-the-phone technical advice

Available dealer services at reasonable costs (ie., wrecker services, locksmithkey service, glass repair, etc.)

8-5

ROADSIDE Courtesy TM Care PROVIDES:

Roadside Basic Care services (as outlined above) Plus: FREE Non-Warranty Towing (to the closest dealer from a legal roadway) FREE Locksmith/Key Service (when keys are lost on the road or locked inside) FREE Jump Start (at home or on the road) FREE Fuel Delivery ($5 of fuel delivered on the road)

Chevrolet/Geo offers Courtesy Transportation for customers needing warranty service. Courtesy Transportation will be offered in conjunction with the coverage provided by the Bumper to Bumper New Vehicle Limited Warranty to eligible purchasers of 1997 Chevrolet/Geo passenger car and light duty trucks. (Please see your selling dealer for details.) Note: Courtesy Care is available to Retail and Retail Lease Customers operating 1997 and newer ChevroletlGeo vehicles for a period of 3 years/36,000 miles (60 OOO km), whichever occurs first. All Courtesy Care services must be pre-arranged by Chevrolet Roadside or dealer Service Management. Basic Cure and Courtesy Care are not part of or included in the coverage provided by the New Vehicle Limited Warranty. Chevrolet reserves the right to modify or discontinue Basic Care and Courtesy Care at any time.

Please refer to the Roadside Assistance brochure inside your owner information portfolio for full program details. Canadian Roadside Assistance Vehicles purchased in Canada have an extensive Roadside Assistance program accessible from anywhere in Canada or the United States. Please refer to the separate brochure provided by the dealer or call 1-800-268-6800 for emergency services.

For complete program details, see your Chevrolet/Geo dealer to obtain a Roadside Assistance Center brochure. The Roadside Assistance Center uses companies that will provide you with quality and priority service. When roadside services are required, our advisors will explain any payment obligations that may be incurred for utilizing outside services. For prompt assistance when calling, please have the following available to give to the advisor: Vehicle Identification Number (VIN) License plate number Vehicle color Vehicle location Telephone number where you can be reached Vehicle mileage Description of problem

8-7

Courtesy Transportation Chevrolet/Geo offers Courtesy Transportation for customers needing warranty service. Courtesy Transportation will be offered in conjunction with the coverage provided by the Bumper to Bumper New Vehicle Limited Warranty to retail purchasers of 1997 ChevroletlGeo passenger cars and light duty trucks (please see your selling dealer for details). Courtesy Transportation includes:

One way shuttle ride for any warranty repair completed during the same day. Up to $30 maximum daily vehicle rental allowance for any overnight warranty repair up to five days, OR Up to $30 maximum daily cab, bus or other transportation allowance in lieu of rental for any overnight warranty repair up to five days, OR Up to $10 daily fuel allowance for rides provided by another person (i.e., friend, neighbor, etc.) in lieu of rental for any overnight warranty repair up to five days. Note: All Courtesy Transportation arrangements will be administered by your ChevroletIGeo dealer service management. Claim amounts should reflect all actual costs.

ChevroletIGeo Courtesy Transportation is not part of the Bumper to Bumper New Vehicle Limited Warranty. ChevroletIGeo reserves the right to make any changes or discontinue Courtesy Transportation at any time without notification.

0 For additional program details, contact your

Chevrolet/Geo dealer.

Some state insurance regulations make it impractical to rent vehicles to people under 21 years of age. If you are under 21 and have difficulty renting a vehicle, Chevrolet will reimburse up to $30/day for documented transportation you receive. For warranty repairs during the Complete Vehicle Coverage period in the New Vehicle Limited Warranty, interim transportation may be available under the Courtesy Transportation Program. Please consult your dealer for details. The Roadside Assistance program is available only in the United States and Canada. In Canada, please consult your GM dealer for information on Courtesy Transportation.

GM Participation in an Alternative Dispute Resolution Program This program is available in all 50 states and the District of Columbia. Canadian owners refer to your Warranty and Owner Assistance Information booklet for information on the Canadian Motor Vehicle Arbitration Plan (CAMVAP). General Motors reserves the right to change eligibility limitations and/or to discontinue its participation in this program. Both Chevrolet and your Chevrolet dealer are committed to making sure you are completely satisfied with your new vehicle. Our experience has shown that, if a situation arises where you feel your concern has not been adequately addressed, the Customer Satisfaction Procedure described earlier in this section is very successful. There may be instances where an impartial third party can assist in arriving at a solution to a disagreement regarding vehicle repairs or interpretation of the New Vehicle Limited Warranty. To assist in resolving these disagreements, Chevrolet voluntarily participates in BBB AUTO LINE.

BBB AUTO LINE is an out-of-court program administered by the Better Business Bureau system to settle automotive disputes. This program is available free of charge to customers who currently own or lease a GM vehicle. If you are not satisfied after following the Customer Satisfaction Procedure, you may contact the BBB using the toll-free telephone number, or write them at the following address:

BBB AUTO LINE Council of Better Business Bureaus, Inc. 4200 Wilson Boulevard Suite 800 Arlington, VA 22203- 1804 Telephone: 1-800-955-5 100

To file a claim, you will be asked to provide your name and address, your Vehicle Identification Number (VIN) and a statement of the nature of your complaint. Eligibility is limited by vehicle age and mileage, and other factors.

8-9

We prefer you utilize the Customer Satisfaction Procedure before you resort to AUTO LINE, but you may contact the BBB at any time. The BBB will attempt to resolve the complaint serving as an intermediary. If this mediation is unsuccessful, an informal hearing will be scheduled where eligible customers may present their case to an impartial third-party arbitrator. The arbitrator will make a decision which you may accept or reject. If you accept the decision, GM will be bound by that decision. The entire dispute resolution procedure should ordinarily take about 40 days from the time you file a claim until a decision is made. Some state laws may require you to use this program before filing a claim with a state-run arbitration program or in the courts. For further information, contact the BBB at 1-800-955-5100 or the Chevrolet Customer Assistance Center at 1-800-222-1020. Warranty Information Your vehicle comes with a separate warranty booklet that contains detailed warranty information.

REPORTING SAFETY DEFECTS TO THE UNITED STATES GOVERNMENT If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA), in addition to notifying General Motors. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer or General Motors. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in the Washington, D.C. area) or write to:

NHTS A, U .S. Department of Transportation Washington, D.C. 20590

You can also obtain other information about motor vehicle safety from the Hotline.

I *-lo.,

. .~

,,. ,,, , ,

._

.- .

. ... .

REPORTING SAFETY DEFECTS TO THE CANADIAN GOVERNMENT If you live in Canada, and you believe that your vehicle has a safety defect, you should immediately notify Transport Canada, in addition to notifying General Motors of Canada Limited. You may write to:

Transport Canada Box 8880 Ottawa, Ontario K1G 352

REPORTING SAFETY DEFECTS TO GENERAL MOTORS In addition to notifying NHTSA (or Transport Canada) in a situation like this, we certainly hope you’ll notify us. Please call us at 1-800-222-1020 or write:

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 7047 Troy, Michigan 48007-7047

In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French). Or, write: General Motors of Canada Limited Customer Communication Centre, 163-005 1908 Colonel Sam Drive Oshawa, Ontario LlH 8P7

Ordering Service and Owner Publications in Canada Service manuals, service bulletins, owner’s rn Lan uals and other service literature are available for purchase for all current and past model General Motors vehicles. The toll-free telephone number for ordering information in Canada is 1-800-668-5539.

8-11

1997 CHEVROLET/GEO SERVICE PUBLICATIONS ORDERING INFORMATION

The following publications covering the operation and servicing of your vehicle can be purchased by filling out

the Service Publication Order Form in this book and mailing

it in with your check, money order,

or credit card information to Helm, Incorporated (address below.)

CURRENT PUBLICATIONS FOR 1997 CHEVROLET/GEO

SERVICE MANUALS Service Manuals have the diagnosis and repair information on engines, transmission, axle, suspension, brakes, electrical, steering, body, etc. RETAIL SELL PRICE: $90.00

TRANSMISSION, TRANSAXLE, TRANSFER CASE UNIT REPAIR MANUAL This manual provides information on unit repair service procedures, adjustments and specifications for the 1997 GM transmissions, transaxles and transfer cases. RETAIL SELL PRICE: $40.00

SERVICE BULLETINS Service Bulletins give technical service information needed to knowledgeably service General Motors cars and trucks. Each bulletin contains instructions to assist diagnosis and service of your vehicle.

in the

OWNER’S INFORMATION Owner publications are written directly for Owners and intended to provide basic operational information about the vehicle. The owner’s manual will include the Maintenance Schedule for all models. In-Portfolio: Includes a Portfolio, Owner’s Manual and Warranty Booklet. RETAIL SELL PRICE: $1 5.00 Without Portfolio: Owner’s Manual only. RETAIL SELL PRICE: $10.00 CURRENT 81 PAST MODEL ORDER FORMS Service Publications are available for current and past model GM vehicles. To request an order form, please specify year and model name of the vehicle.

r ORDER TOLL FREE

(NOTE: For Credit Card Holders Only) (Mondav-Fridav 8:OO AM - 6:OO PM EST)

1-800-782-4356

NOTE: Dealers and Companies please provide dealer or company name, and also the name of the person to whose attention the shipment should be sent.

HELM, INCORPORATED P.O. Box 07130 Detroit, MI 48207 For purchases outside U.S.A. please write to the above address for quotation.

s Mail completed order form to: p (CUSTOMER’S

NAME) (ATTENTION)

I T (STREET ADDRESS-NO P.O. BOX NUMBERS) 0 (CITY)

(STATE)

(ZIP CODE)

DAYTIME

TELEPHONE

NO.

GM-CHE-ORD97 *(Prices are subject to

AREA CODE change without notice and without incurring

obligation. Allow ample time for delivery.)

CUSTOMER SIGNATURE

Note to Canadian Customers: All listed prices are quoted in US. funds. Canadian residents are to make checks payable in U.S. funds. To cover Canadian postage, add $11.50 plus the US. order processing.

f i NOTES

8-14

e Section 9 Index

Accessory Outlet .............................. 2-58 Accessory Power Plug ........................... 6-61 Adding Equipment to the Outside of Your Vehicle . . . . . . 6-3 AirBag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-19 How Does It Restrain .......................... 1-23 How It Works ................................ 1-2 1 Location .................................... 1-21 Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-24 ......................... 1-22 What Makes It Inflate What Will You See After It Inflates . . . . . . . . . . . . . . . 1-23 When Should It Inflate ......................... 1-22 Air Bag Readiness Light 1-20, 2-72 AirBagSystem ................................ 1-19 Aircleaner .................................... 6-16 Air Conditioning ....................... 3-4,3-9, 3-11 Alignment and Balance, Tire ...................... 6-48 Aluminum Wheels, Cleaning ...................... 6-57 Antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-30 Antifreeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-22 Anti-Lock Brakes ...................................... 4-7 Brake System Warning Light . . . . . . . . . . . . . . . . 2-74, 4-7 Anti-Theft Radio ............................... 3-26 Appearancecare ............................... 6-51 ....................... 6-59 Appearance Care Materials

....................

Arbitration Program .............................. 8-9 Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-57 Audio Equipment. Adding ........................ 3-29 Audio Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13 Automatic

Electronic Dual Climate Control System . . . . . . . . . . . . 3-5 Overdrive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-28 Transmission Check ........................... 7-14 Transmission Fluid ............................ 6-18 ....................... 2-26 Transmission. Operation . . . . . . . . . . . . 7-16 Transmission. Park Mechanism Check Transmission. Shifting ......................... 2-26 Transmission. Starting Your Engine . . . . . . . . . . . . . . 2-22 Axle. Limited-Slip Rear ......................... 2-38 Axle. Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-22

Back-up Lamp Bulb Replacement . . . . . . . . . . . . . . . . . 6-37 Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-32 Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3 Replacement, Remote Function Actuation System ... 2-12 Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-3, 5-5 BBB Auto Line ................................. 8-9 Belt, Engine Accessory .......................... 6-71 Better Business Bureau Mediation . . . . . . . . . . . . . . . . . . . 8-9 Blizzard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-28

Brake

Adjustment .................................. 6-31 Fluid ....................................... 6-29 Master Cylinder .............................. 6-29 Parking ..................................... 2-32 PedalTravel ................................. 6-31 Replacing System Parts ........................ 6-32 System Warning Light ......................... 2-73 Transmission Shift Interlock .................... 2-35 Wear ....................................... 6-31 Brakes.Anti -Lock ............................... 4-7 Brake-Transmission Shift Interlock Check ........... 7- 15 Braking ........................................ 4-6 Braking in Emergencies .......................... 4- 11 .......................... Break-In. New Vehicle 2- 19 BTSI ......................................... 2-35 BTSICheck ................................... 7-15 Bulb Replacement .........................

6.33. 6.69

8-7 6-69

2.15.2.37. 4.29

Canadian Roadside Assistance .................... Capacities and Specifications ...................... Carbon Monoxide .................... Cassette Deck Service ........................... 7- 13 Cassette Tape Player ............................ 3- 14 Careofyour ................................. 3-29 Center Console ................................. 2-55 Certification Label .............................. 4-30 Chains. Tire ................................... 6-51 Check Gages Light .............................. 2-79 Checking Your Restraint Systems .................. 1-33 Chemical Paint Spotting .......................... 6-58 9-2

Child Restraints ......................

1.25. 1.26. 1-27 Securing in the Passenger Seat Position ........... 1-27 Top Strap ................................... 1-27 ................................ 1-27 Where to Put ............................... 2-57 Cigarette Lighter ....................... 6-63 Circuit Breakers and Fuses Cleaner. Air ................................... 6-16 Cleaning Aluminum Wheels ............................ 6-57 Coated Moldings ............................. 6-53 Convenience Net ............................. 6-53 Exterior LampsLenses ........................ 6-56 Fabric ...................................... 6-52 Glasssurfaces ............................... 6-54 Inside of Your Corvette ........................ 6-52 ............................. 6-53 Instrument Panel Leather ..................................... 6-53 Outside of Your Corvette ....................... 6-55 Removable Roof Panel ......................... 6-55 SecurityShade ............................... 6-53 Soft-Touch Paint Surfaces ...................... 6-53 Stains ...................................... 6-52 Tires ....................................... 6-57 Vinyl ....................................... 6-52 Weatherstrips ................................ 6-55 Wheels ..................................... 6-57 Windshield and Wiper Blades . . . . . . . . . . . . . . . . . . . 6-54 Climate Control ................................. 3-5 Automatic Electronic Dual ....................... 3-5 Manual ...................................... 3-2 Clock. Setting the ............................... 3-13 Clutch. Hydraulic ............................... 6-20

. . . . .

. . . . .

.........

3- 1 3-5 3-2

Compact Disc

Comfort Controls ................................ Automatic Electronic Dual ....................... Manual ...................................... Adapter Kit .................................. 3-18 Care ....................................... 3-30 Changer, Trunk Mounted ....................... 3-22 Player . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-18 ............................ 2-24 Competitive Driving Console, Center ................................ 2-55 Control of a Vehicle .............................. 4-6 Convenience Net ............................... 2-57 Convenience Net, Cleaning ....................... 6-53 Convex Outside Mirror .......................... 2-54 Coolant ............................. 5-13,5-18, 6-22 SurgeTank .................................. 5-18 Surge Tank Pressure Cap ....................... 6-26 .......................... Coolant Heater, Engine 2-24 Cooling System ................................ 5- 16 CourtesyLamps ................................ 2-52 Courtesy Transportation In Canada ..................................... 8-8 1ntheU.S. ................................... 8-8 Cruise Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-47 Customer Assistance for Text Telephone Users . . . . . . . . . 8-4 Customer Assistance Information . . . . . . . . . . . . . . . . . . . 8- 1 Customer Satisfaction Procedure .................... 8-2

Damage. Finish ............................... Daytime Running Lamps ......................... ................................... Dead Battery

6-57 2-50 5-3

3.4. 3.10

3.3.3.9. 3.12

6-71 3-17

8-10 8-11 8-11 4-2

Defects. Reporting Safety

.....................

........................ InCanada ................................... To General Motors ............................ Defensive Driving ............................... Defogger. Rear Window Defogging ....................... 3.3.3.8.3.10. 3.12 Defrosting ............................ ............................ Dimensions. Vehicle Dolby B Noise Reduction ........................ Door Locks ....................................... 2-4 PowerLocks .................................. 2-5 Downshifting .................................. 2-31 Drive, Automatic Transmission .................... 2-28 Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 2-81 Controls and Displays ......................... 2-82 Warnings and Messages ........................ 2-90 ABS (Anti-Lock Brake System) Active . . . . . . . . . . . . 2-91 Charge System Fault .......................... 2-92 Coolant Over Temp ........................... 2-94 Flat Tire - (If, lr, rf, rr) ......................... 2-96 High Oil Temperature Reduce Engine Rpm . . . . . . . . 2-94 High Tire Pressure - (If. Ir, rf. IT) . . . . . . . . . . . . . . . . . 2-96 High Trans Temp ............................. 2-94 LowOilLevel ............................... 2-91 Low Oil Pressure ............................. 2-91 Low Tire Pressure - (If, lr. rf, rr) . . . . . . . . . . . . . . . . . 2-95 Maximum Speed 80 Mph (129 M h ) . . . . . . . . . . . . . 2-93 Reduced Engine Power ........................ 2-92 Service ABS ................................. 2-91

Driver Information Center (DIC) Messages

9-3

Driver Information Center (DIC) Messages (Continued)

Service Column Lock .......................... 2-91 Service Ride Control .......................... 2-93 Service Tire Monitor (MON) System (SYS) ........ 2-97 ....................... 2-93 Service Traction System Shocks Inoperative ............................ 2-93 Traction System (SYS) Active ................... 2-92 DriverPosition ................................. 1-12 Driving ........................................ 4-1 City ........................................ 4-21 Defensive .................................... 4-2 Drunken ..................................... 4-2 Freeway .................................... 4-22 InaBlizzard ................................. 4-28 In Foreign Countries ........................... 6-5 In the Rain .................................. 4- 18 Night ...................................... 4-16 OnCurves .................................. 4-11 On Hill and Mountain Roads .................... 4-24 On Snow and Ice ............................. 4-27 Through Deep Water .......................... 4-20 WetRoads .................................. 4-18 Winter ...................................... 4-26 Drunken Driving ................................ 4-2

Electrical Equipment. Adding .......... 2-23,3-29, 6-61 Electrical System ............................... 6-61 Electronic Dual Climate Control System .............. 3-5 EMT (Extented Mobility Tire) ..................... 6-41 Engine ....................................... 6-10 AccessoryBelt ............................... 6-71

2-24 7-13 13

5.13.5.18. 6.22

Coolant ........................... Coolant Heater ............................... Coolant Level Check .......................... Coolant Temperature Gage . . . . . . . . . . . . . . . . 2.75. 5. Exhaust ........................... 2.15.2.37. 4.29 FuseBlock .................................. 6-66 Identification ................................ 6-60 Oil ........................................ 6-11 Oil, Adding ................................. 6-12 Oil, Additives ................................ 6-15 Oil. Checking ................................ 6-12 OilLevelCheck .............................. 7-13 Oil, Life Monitor ............................. 6-15 Oil, Pressure Gage ............................ 2-78 ................................... Oil, Used 6-16 Oil, When to Change .......................... 6-15 Overheated Engine Protection Operating Mode . . . . . 5-13 Overheating ................................. 5-13 Running While Parked ......................... 2-37 Specifications ................................ 6-69 StartingYour ................................ 2-22 EnglishMetric Button ........................... 2-71 Ethanol ........................................ 6-4 Exhaust, Engine ...................... 2-15,2-37, 4-29 Express-Down Window .......................... 2-39 ......................... Extended Mobility Tires 6-41 Exterior Lamps ................................. 2-50 Fabric Cleaning ............................... Fabric Protection ............................... Fan Control Buttons .......................... Feature, Theft-Deterrent .........................

6-52 6-52 3-2, 3-8 2-16

Fiberglass Springs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-58 Fifth Gear. Manual Transmission . . . . . . . . . . . . . . . . . . . 2-29 Filling Your Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6- 16 Filter. Air Cleaner Finish Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-56 Finish Damage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-57 . . . . . . . . . . . . . . . . 2-28 First Gear. Automatic Transmission First Gear. Manual Transmission . . . . . . . . . . . . . . . . . . . 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . 5-2 Flashers. Hazard Warning Flat Tire. What to Do . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-22 Floor Mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-60 Fluid Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-70 FobTraining . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-89 FogLamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-51 Foreign Countries, Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5 . . . . . . . . . . . . . . . . . 2-29 Fourth Gear. Manual Transmission .. French 11 Front Sidemarker Lamp Bulb Replacement . . . . . . . . . . . 6-35 FrontTowing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10 Front Turn Signal Lamp Bulb Replacement . . . . . . . . . . 6-35 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-3 6-4 2-80 6-5 6-5 6-63

Canada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . In Foreign Countries ........................... Fuel. Filling Your Tank ....................... Fuses and Circuit Breakers

...........................

Language

GAWR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.30. 4.31 Gear Positions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-26 Gross Axle Weight Rating . . . . . . . . . . . . . . . . . . . 4.30. 4.31 Gross Vehicle Weight Rating . . . . . . . . . . . . . . . . . 4.30. 4-31 .. Guide en Franpis 11 GVWR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.30. 4.31

HighLow Beamchanger Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Halogen Bulbs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-33 Hazard Warning Flashers . . . . . . . . . . . . . . . . . . . . . . . . . . 5-2 Headlamp Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-44 Headlamp/Highbeams Bulb Replacement . . . . . . . . . . . . 6-33 Headlamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-43 . . . . . . . . . . . . . . . . . . . . . . 2-45 Hearing Impaired, Customer Assistance . . . . . . . . . . . . . . 8-4 Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12 Heritage Pages 111 ... High-Beam Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-45 Highway Hypnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24 . . . . . . . . . . . . . 4-24 Hill and Mountain Roads Hood . . . . . . . . . . . . . . 6-8 6-8 2-40 6-20 . . . 4-20

Checking Things Under . . . . . . Release . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Hydraulic Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Hydroplaning . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . .

G a g e s

Engine Coolant Temperature .................... Engine Oil Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Voltmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2-75 2-78 2-81 2-73

. . . . . . . . . . . . . . . 2-20 Ignition Switch . . . . . . . . . . . . . . Inadvertent Load Control . . . . . . . . . . . . . . . . . . . . . . 2-53 Inflation. Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-43 Inside Daymight Rearview Mirror . . . . . . . . . . . . . . . . . 2-53 9-5

Inspections .................................... 7-17 Brakesystem ................................ 7-17 Exhaust System .............................. 7-17 Radiator and Heater Hose ...................... 7-17 Steering .................................... 7-17 Suspension .................................. 7-17 Tire ........................................ 7-17 Wheel ...................................... 7-17 InstrumentPanel ............................... 2-68 Brightness Control ............................ 2-52 Cleaning .................................... 6-53 Cluster ..................................... 2-7 0 FuseBlock .................................. 6-63 Instrument Panel Cupholder ....................... 2-54 Interior Lamps ................................. 2-52 Jump Starting .................................. 5-3 K e y Fob Transmitter ............................ 2-6 Key Lock Cylinders Service ...................... 7-14 Keys .......................................... 2-2 Labels ....................................... 4-30 Certification ................................. 4-30 Service Parts Identification ..................... 6-60 Tire-Loading Information ...................... 4-30 Vehicle Identification Number . . . . . . . . . . . . . . . . . . . 6-60 Cleaning Exterior LampsLenses ................. 6-56 Courtesy .................................... 2-52 Exterior .................................... 2-50 Interior ..................................... 2-52 OnReminder ................................ 2-44

Lamps

Latches. Seatback ................................ 1-5 Leaving Your Vehicle ............................. 2-5 Leaving Your Vehicle with the Engine Running . . . . . . . 2-34 Lighter ....................................... 2-57 Lights

Air Bag Readiness ....................... 1-20, 2-72 Anti-Lock Brake System Warning . . . . . . . . . . . . 2-74, 4-7 Brake System Warning ......................... 2-73 Check Engine ................................ 2-76 CheckGages ................................ 2-79 Safety Belt Reminder ...................... 1-7, 2-72 Security .................................... 2-79 Traction Control System (TCS) .................. 2-75 ........................... 4-30 Loading Your Vehicle Locks ......................................... 2-4 Cylinders ................................... 7-14 Door ........................................ 2-4 Ignition Transmission Lock Check ............... 7-16 Key Lock Cylinders Service .................... 7-14 PowerDoor .................................. 2-5 Using the Wheel Lock Key ..................... 6-50 Lubricants and Fluids ............................ 7-18 Lubrication Service, Body ........................ 7-14 Maintenance Record ........................... Maintenance Schedule ............................

7-20 7-1 Periodic Maintenance Inspections ................ 7-17 Recommended Fluids and Lubricants . . . . . . . . . . . . . 7-18 Scheduled Maintenance Services . . . . . . . . . . . . . . . . . . 7-4 ................ 7-2 Your Vehicle and the Environment 6-57 2-76

Maintenance, Underbody ......................... Malfunction Indicator Lamp ......................

Manual

........................ 3-2 Comfort Control System Frontseat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 Transmission Check ........................... 7- 14 Transmission Fluid ............................ 6- 19 Transmission. Shifting ......................... 2-29 Transmission. Starting Your Engine . . . . . . . . . . . . . . 2-22 Memory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-5 Methanol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6- 4 Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-53 Convex Outside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-54 Inside Daymight Rearview ..................... 2-53 Power Remote Control ......................... 2-54 Visor Vanity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-58 MMT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6- 4 Mountain Roads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-24 Multifunction Lever ............................. 2-4 1

Neutral

. . . . . . . . . . . . . . . . . . . . . . . Automatic Transmission Manual Transmission .......................... New Vehicle Break-In ........................... Nightvision . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2-27 2-29 2-19 4-17

Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . . . . . . 4- 13 Oil. Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-11 OnetoFourLight ............................... 2-30 Outlet. Accessory ............................... 2-58 . . . . . . . . . . . . . . . . 2-28 Overdrive. Automatic Transmission Overheated Engine Protection Operating Mode . . . . . . . 5- 13 Overheating Engine ............................. 5- 13

Owner Checks and Services ....................... Owner Publications. Ordering ..................... InCanada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

7-13 8-12 8-11

6-58

Parking

2-26 2-33 2-35

Paint Spotting. Chemical ........................ Park ....................... Automatic Transmission Shifting Into ................................. Shifting Out of . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AtNight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16 Brake ...................................... 2-32 Lots . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-16 Over Things That Burn ........................ 2-36 Your Vehicle. Manual Transmission . . . . . . . . . . . . . . 2-36 Parkmg Brake Mechanism Check . . . . . . . . . . . . . . . . . . 7-16 Passenger Position .............................. 1-19 ................................... Passing 4-13 Pass-Key -4D- . 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Periodic Maintenance Inspections . . . . . . . . . . . . . . . . . . 7-17 Power

DoorLocks ................................... 2-5 Remote Control Mirrors ........................ 2-54 Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11 Steering Fluid ................................ 6-26 Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-39 Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-61 Powerseat ..................................... 1-2 Pregnancy. Use of Safety Belts .................... 1-18 Problems on the Road ............................ 5-1 9-7

Publications. Service and Owner . . . . . . . . . . . . . . . . . 8- 12 8-11

InCanada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Racing or Other Competitive Driving . . . . . . . . . . . . . . 2-24 RadioReception . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-28 Radios . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13 Rain. Driving In . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4- 18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-53 Reading Lamps Rear . . . . . . . . . . . . . . . . . . . . . . 6-22 7-17 2-56 5-11 . . . . . . . 6-35 3-4, 3-10 Rearview Mirror, Inside Daymight . . . . . . . . . . . . . . . . . 2-53 Reclining Seatbacks .............................. 1-3 Recommended Fluids and Lubricants . . . . . . . . . . . . . . . 7- 18 Remote Function Actuation (RFA) System

Axle . . . . . . . . . . . . . . . . . . .................... Axle Service Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Turn Signal and Taillamp Bulb Replacement Window Defogger ........................

Battery Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . 2- 12 Resynchronizing Your Transmitter . . . . . . . . . . . . . . . 2- 1 1 Remote Hatch Release ........................... 2- 14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-69 Replacement Bulbs Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-48 Replacement, Wheel Reporting Safety Defects . . . . . . . . . . . . . . . . . . . . . . . 8-10 . . . . . . . . . . 8-11 . . . . . . . . . . 8-11 Resetting the Oil Life Monitor . . . . . . . . . . . . . . . . . . . 6-15 Restraints

In Canada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . To General Motors

Checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

1-33

9-8

1.25. 1.26.

1-27 Child . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Replacing Parts After a Crash . . . . . . . . . . . . . . . . . . . 1-34 Systemcheck ................................ 7-14 Retained Accessory Power (RAP) . . . . . . . . . . . . . . . . . . 2-21 Reverse

....................... 2-27 Automatic Transmission Manual Transmission .......................... 2-29 Ridecontrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-38 Roadside Assistance .............................. 8-5 Roadside Assistance. Canadian ..................... 8-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-23 Rocking Your Vehicle RoofPanel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-60 Rotation. Tire .................................. 6-44

Safety Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-6 Adults ...................................... 1-11 Care ....................................... 6-54 Children . . . . . . . . . . . . . . . . . . . . . . . . . . 1-25. 1-26. 1-27 Driver Position . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-12 Extender . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-33 How to Wear Properly ......................... 1-11 . . . . . . . . . . . . . . . . . . . . 1-14. 1-31. 1-32 Incorrect Usage ........................ 1-13 Lap Belt Cinch Feature Lap-Shoulder . . . . . . . .................... 1-12 .............................. 1-30 Larger Children Passenger Position . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-19 ........................ 1-10 Questions and Answers 1-7. 2-72 Reminder Light Replacing After a Crash ........................ 1-34 Smaller Children and Babies . . . . . . . . . . 1-25. 1-26. 1-27 Use During Pregnancy ......................... WhyThey Work ...............................

..........................

1-18 1-7

8- 10 8-11 8-1 1 ... vm 7-5

Safety Defects. Reporting

........................ InCanada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . To General Motors . . . . . . . . . . . . . . . . . . . . . . . . . . . . Safety Warnings and Symbols ...................... Scheduled Maintenance Services .................... Seatback Latches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-5 Reclining . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 ManualFront ................................. 1-2 Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 Securing a Child Restraint . . . . . . . . . . . . . . . . . . . . . . 1-27 sport . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 Seats and Restraint Systems ........................ 1-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . Seats and Seat Controls 1-2 . . . . . . . . . . . . . . 2-28 Second Gear, Automatic Transmission Second Gear, Manual Transmission . . . . . . . . . . . . . . . . . 2-29 Security Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-79 SecurityShade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-55 . . . . . 6-53 Security Shade, Cleaning . . 2-38 Real Selective Time Damping Service Bulletins, Ordering ............................ Manuals, Ordering ............................ Parts Identification Label ....................... Publications, Ordering ......................... ......................... Work, Doing Your Own

8- 12 8- 12 6-60 8- 12 6-2 . . . . . . . . . . . . . . . . . . . . . . 6-1 Service and Appearance Care . . . . . . . . . . . . . . . . . . . 8- 12 Service and Owner Publications 8-11 Servicing Your Air Bag-Equipped Corvette . . . . . . . . . . 1-24

InCanada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . .

. . .

. .

...................... .........................

Shift Speeds . . . 2-30 Shifting . . . . . . .