1996 Chevrolet Camaro Owners Manual

match or get them on a hot part of the vehicle. Some are dangerous if you breathe their fumes in a closed space. When you use anything from a container to clean your Chevrolet, be sure to follow the manufacturer’s warnings and instructions. And always open your doors or windows when you’re cleaning the inside. Never use these to clean your vehicle:

Gasoline Benzene 0 Naphtha

Carbon Tetrachloride Acetone Paint Thinner

0 Turpentine

Lacquer Thinner Nail Polish Remover

They can all be hazardous -- some more than others -- and they can all damage your vehicle, too.

6-56

Don’t use any of these unless this manual says you can. In many uses, these will damage your vehicle:

Alcohol Laundry Soap Bleach

0 Reducing Agents Cleaning the Inside of Your Chevrolet Use a vacuum cleaner often to get rid of dust and loose dirt. Wipe vinyl or leather with a clean, damp cloth. Your Chevrolet dealer has two GM cleaners, a solvent-type spot lifter and a foam-type powdered cleaner. They will clean normal spots and stains very well. Do not use them on vinyl or leather. Here are some cleaning tips: 0 Always read the instructions on the cleaner label. 0 Clean up stains as soon as you can -- before they set. 0 Use a clean cloth or sponge, and change to a clean area often. A soft brush may be used if stains are stubborn.

0 Use solvent-type cleaners in a well-ventilated area

only. If you use them, don’t saturate the stained area. If a ring forms after spot cleaning, clean the entire area immediately or it will set.

Using Foam-mpe Cleaner on Fabric 1.

Vacuum and brush the area to remove any loose dirt. Always clean a whole trim panel or section. Mask surrounding trim along stitch or welt lines. Mix Multi-Purpose Powdered Cleaner following the directions on the container label. Use suds only and apply with a clean sponge. Don’t saturate the material. Don’t rub it roughly. As soon as you’ve cleaned the section, use a sponge to remove the suds. Rinse the section with a clean, wet sponge. Wipe off what’s left with a slightly damp paper towel or cloth. Then dry it immediately with a blow dryer. Wipe with a clean cloth.

2.

3.

4. 5. 6. 7.

8. 9.

10. 11.

Using Solvent-Qpe Cleaner on Fabric First, see if you have to use solvent-type cleaner at all. Some spots and stains will clean off better with just water and mild soap. If you need to use a solvent:

Gently scrape excess soil from the trim material with a clean, dull knife or scraper. Use very little cleaner, light pressure and clean cloths (preferably cheesecloth). Cleaning should start at the outside of the stain, “feathering” toward the center. Keep changing to a clean section of the cloth. When you clean a stain from fabric, immediately dry the area with a blow dryer to help prevent a cleaning ring.

Fabric Protection Your Chevrolet has upholstery and carpet that has been treated with Scotchgard” Fabric Protector, a 3M product. It protects fabrics by repelling oil and water, which are the carriers of most stains. Even with this protection, you still need to clean your upholstery and carpet often to keep it looking new. Further information on cleaning is available by calling 1-800-433-3296 (in Minnesota, 1-800-642-6 167).

6-57

Special Cleaning Problems Greasy or Oily Stains Stains caused by grease, oil, butter, margarine, shoe polish, coffee with cream, chewing gum, cosmetic creams, vegetable oils, wax crayon, tar and asphalt can be removed as follows: 1. 2.

Carefully scrape off excess stain. Follow the solvent-type instructions described earlier. Shoe polish, wax crayon, tar and asphalt will stain if left on a vehicle’s seat fabric. They should be removed as soon as possible. Be careful, because the cleaner will dissolve them and may cause them to spread.

3.

Non-Greasy Stains Stains caused by catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, wine, vomit, urine and blood can be removed as follows: 1. Carefully scrape off excess stain, then sponge the

soiled area with cool water.

2. If a stain remains, follow the foam-type instructions

described earlier.

6-58

3. If an odor lingers after cleaning vomit or urine, treat the area with a water/baking soda solution: 1 teaspoon (5 ml) of baking soda to 1 cup (250 ml) of lukewarm water.

4. If needed, clean lightly with solvent-type cleaner.

Combination Stains Stains caused by candy, ice cream, mayonnaise, chili sauce and unknown stains can be removed as follows:

Carefully scrape off excess stain, then clean with cool water and allow to dry. If a stain remains, clean it with solvent-type cleaner.

Cleaning Vinyl Use warm water and a clean cloth.

Rub with a clean, damp cloth to remove dirt. You may have to do it more than once. Things like tar, asphalt and shoe polish will stain if you don’t get them off quickly. Use a clean cloth and a GM Vinylkeather Cleaner or equivalent product.

Cleaning Leather Use a soft cloth with lukewarm water and a mild soap or saddle soap. 0 For stubborn stains, use a GM VinylLeather Cleaner

or equivalent product. Never use oils, varnishes, solvent-based or abrasive cleaners, furniture polish or shoe polish on leather. Soiled leather should be cleaned immediately. If dirt is allowed to work into the finish, it can harm the leather.

Cleaning the Top of the Instrument Panel Use only mild soap and water to clean the top surfaces of the instrument panel. Sprays containing silicones or waxes may cause annoying reflections in the windshield and even make it difficult to see through the windshield under certain conditions.

Care of Safety Belts Keep belts clean and dry.

I A CAUTIGlv: I - --

Do not bleach or dye safety belts. If you do, it may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.

Glass Glass should be cleaned often. GM Glass Cleaner (GM Part No. 1050427) or a liquid household glass cleaner will remove normal tobacco smoke and dust films. Don’t use abrasive cleaners on glass, because they may cause scratches. Avoid placing decals on the inside rear window, since they may have to be scraped off later. If abrasive cleaners are used on the inside of the rear window, an electric defogger element may be damaged. Any temporary license should not be attached across the defogger grid.

6-59

Weatherstrips Silicone grease on weatherstrips will make them last longer, seal better, and not stick or squeak. Apply silicone grease with a clean cloth at least every six months. During very cold, damp weather more frequent application may be required. (See “Recommended Fluids and Lubricants” in the Index.) Cleaning a Removable Roof Panel Special care is necessary when cleaning, removing and/or storing the roof panel. 0 Flush with water to remove dust and dirt, then dry

the panel.

0 Clean the panel with GM Glass Cleaner. Leave the cleaner on the panel for one minute, then wipe the panel with a soft, lint-free cloth.

0 Don’t use abrasive cleaning materials.

Cleaning the Outside of the Windshield and Wiper Blades If the windshield is not clear after using the windshield washer, or if the wiper blade chatters when running, wax or other material may be on the blade or windshield. Clean the outside of the windshield with GM Windshield Cleaner, Bon-Ami Powder@ (GM Part No. 1050011). The windshield is clean if beads do not form when you rinse it with water. Clean the blade by wiping vigorously with a cloth soaked in full-strength windshield washer solvent. Then rinse the blade with water. Wiper blades should be checked on a regular basis and replaced when worn.

6-60

Cleaning the Outside of Your Chevrolet The paint finish on your vehicle provides beauty, depth of color, gloss retention and durability. Washing Your Vehicle The best way to preserve your vehicle’s finish is to keep it clean by washing it often with lukewarm or cold water. Don’t wash your vehicle in the direct rays of the sun. Don’t use strong soaps or chemical detergents. Use liquid hand, dish or car washing (mild detergent) soaps. Don’t use cleaning agents that are petroleum based, or that contain acid or abrasives. All cleaning agents should be flushed promptly and not allowed to dry on the surface, or they could stain. Dry the finish with a soft, clean chamois or a 100% cotton towel to avoid surface scratches and water spotting. High pressure car washes may cause water to enter your vehicle. Finish Care Occasional waxing or mild polishing of your Chevrolet by hand may be necessary to remove residue from the paint finish. You can get GM-approved cleaning products from your dealer. (See “Appearance Care and Materials” in the Index.)

Your Chevrolet has a “basecoat/clearcoat” paint finish. The clearcoat gives more depth and gloss to the colored basecoat. Always use waxes and polishes that are non-abrasive and made for a basecoatklearcoat paint finish.

NOTICE:

Machine compounding or aggressive polishing on a basecoat/clearcoat paint finish may dull the finish or leave swirl marks.

Foreign materials such as calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, etc., can damage your vehicle’s finish if they remain on painted surfaces. Wash the vehicle as soon as possible. If necessary, use non-abrasive cleaners that are marked safe for painted surfaces to remove foreign matter. Exterior painted surfaces are subject to aging, weather and chemical fallout that can take their toll over a period of years. You can help to keep the paint finish looking new by keeping your Chevrolet garaged or covered whenever possible.

6-61

Cleaning Your Convertible Top Your convertible top should be cleaned often. If you use an automatic car wash, use one with water jets and hanging cloths. When you hand wash the top, do it in partial shade. Use a mild soap, lukewarm water and a soft sponge. A chamois or cloth may leave lint on the top, and a brush can chafe the threads in the top fabric. Don’t use detergents, harsh cleaners, solvents or bleaching agents. When you clean the top, put one hand under it to support it. Wet the entire vehicle and wash the top evenly to avoid spots or rings. Let the soap remain on the fabric for a few minutes. When the top is really dirty, use a mild foam-type cleaner. Thoroughly rinse the entire vehicle, then let the top dry in direct sunlight. To protect the convertible top: 0 After you wash the vehicle, make sure the top is

completely dry before you lower it. Don’t get any cleaner on the vehicle’s painted finish; it could leave streaks. If you decide to go through an automatic car wash, ask the manager if the equipment could damage your top.

Aluminum Wheels (If So Equipped) Keep your wheels clean using a soft clean cloth with mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with a soft clean towel. A wax may then be applied. The surface of these wheels is similar to the painted surface of your car. Don’t use strong soaps, chemicals, abrasive polishes, abrasive cleaners or abrasive cleaning brushes on them because you could damage the surface. Don’t take your vehicle through an automatic car wash that has silicon carbide tire cleaning brushes. These brushes can also damage the surface of these wheels. Tires To clean your tires, use a stiff brush with a tire cleaner.

NOTICE:

When applying a tire dressing always take care to wipe off any overspray or splash from all painted surfaces on the body or wheels of the vehicle. Petroleum-based products may damage the paint finish.

6-62

Sheet Metal Damage If your vehicle is damaged and requires sheet metal repair or replacement, make sure the body repair shop applies anti-corrosion material to the parts repaired or replaced to restore corrosion protection. Finish Damage Any stone chips, fractures or deep scratches in the finish should be repaired right away. Bare metal will corrode quickly and may develop into a major repair expense. Minor chips and scratches can be repaired with touch-up materials available from your dealer or other service outlets. Larger areas of finish damage can be corrected in your dealer’s body and paint shop. Underbody Maintenance Chemicals used for ice and snow removal and dust control can collect on the underbody. If these are not removed, accelerated corrosion (rust) can occur on the underbody parts such as fuel lines, frame, floor pan and exhaust system even though they have corrosion protection.

At least every spring, flush these materials from the underbody with plain water. Clean any areas where mud and other debris can collect. Dirt packed in closed areas of the frame should be loosened before being flushed. Your dealer or an underbody car washing system can do this for you. Chemical Paint Spotting Some weather and atmospheric conditions can create a chemical fallout. Airborne pollutants can fall upon and attack painted surfaces on your vehicle. This damage can take two forms: blotchy, ringlet-shaped discolorations, and small irregular dark spots etched into the paint surface. Although no defect in the paint job causes this, Chevrolet will repair, at no charge to the owner, the surfaces of new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 000 km) of purchase, whichever occurs first.

6-63

Appearance Care Materials Chart

6-64

Service Parts Identification Label You’ll find this label inside your console storage compartment. It’s very helpful if you ever need to order parts. On this label is: 0 your VIN,

the model designation, paint information, and a list of all production options and special equipment.

Be sure that this label is not removed from the vehicle.

Vehicle Identification Number (VIN)

111 1111 111 111111 111 111111 I1 111111111111 SAMPLE4UXTM072675

I GM 1

E N G l N E A 6

CODE MODEL YEAR

ASSEMBLY1 PLANT

This is the legal identifier for your Chevrolet. It appears on a plate in the front corner of the instrument panel, on the driver’s side. You can see it if you look through the windshield from outside your vehicle. The VIN also appears on the Vehicle Certification and Service Parts labels and the certificates of title and registration. Engine Identification The eighth character in your VIN is the engine code. This code will help you identify your engine, specifications and replacement parts.

6-65

Electrical System Add-on Electrical Equipment

I NOTICE:

Don’t add anything electrical to your Chevrolet unless you check with your dealer first. Some electrical equipment can damage your vehicle and the damage wouldn’t be covered by your warranty. Some add-on electrical equipment can keep other components from working as they should.

Your vehicle has an air bag system. Before attempting to atid anything electrical to your Chevrolet, see “Servicing Your Air Bag-Equipped Chevrolet” in the Index.

Headlamps The headlamp wiring is protected by a circuit breaker. An electrical overload will cause the lamps to go on and off, or in some cases to remain off. If this happens, have your headlamp wiring checked right away. Windshield Wipers The windshield wiper motor is protected by a circuit breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools. If the overload is caused by some electrical problem and not snow, etc., be sure to get it fixed. Power Windows and Other Power Options Circuit breakers protect the power windows and other power accessories. When the current load is too heavy, the circuit breaker opens and closes, protecting the circuit until the problem is fixed or goes away.

6-66

Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by a combination of fuses, circuit breakers, and fusible thermal links in the wiring itself. This greatly reduces the chance of fires caused by electrical problems. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the correct size. If you ever have a problem on the road and don’t have a spare fuse, you can borrow one of the correct value. Just pick some feature of your vehicle that you can get along without -- like the radio or cigarette lighter -- and use its fuse, if it is the size you need. Replace it as soon as you can.

Main Fuse Block

The main fuse block is located on the left side of your instrument panel. Open the cover to expose the fuses.

6-67

FUSE USAGE CHART

rl 1
15n

RADIO

ACCY

IP DIMMER

WINDOWS

BATT

141-1 WIPER/WASH

ION PCM

13(1

€I

IGN

DEFOGSEATS

CIGAR/ACCY

AIR BAG

GAGES

Fuse PCM BATT

RADIO ACCY

TAIL LTS

COURTESY

PWR ACCY TAIL

LTS

HVAC

PCM RADIO.ACCY BATT

T U R N B - U

$0

STOP/HAZARD

HVAC

SEE OWNER’S MANUAL FOR MORE INFORMATION

10281549

PRINTED IN U.S.A

Fuse STOP/HAZARD

TURN B-U

Performance/Traction

Usage Hazard Flasher, Brake Switch Assembly

Control Switch, Transmission Range Switch, Back-up Lamp Switch, Turn Flasher, Daytime Running Lamps (DRL) Module

PWR ACCY

COURTESY GAGES

AIR BAG

Usage Powekrain Control Module (PCM), Fuel Pump Relay, Remote Compact Disc Changer Radio Power Antenna, Bose Relay Daytime Running Lamps (DRL) Module, Headlamp Switch HVAC Selector Switch, Rear Defogger Timer Relay, Rear Defogger Switch, Rear Defogger Switch/Timer Park Lamp Relay, Hatch Release Relay, Power Mirror Switch, Radio, Shock Sensor, Instrument Cluster Body Control Module (BCM) Body Control Module (BCM), Brake Switch Assembly’(BTS1). Instrument Cluster, Daytime Running Lamps (DRL) Module, Auxiliary Accessory Wire Air Bag System, Dual Pole Arming Sensor

6-68

Fuse CIGAWACCY

DEFOG/SEATS

PCM IGN

WIPEWASH

WINDOWS

Usage Cigarette Lighter, Data Link Connector (DLC), Auxiliary Accessory Wire Rear Defogger Switchnimer, Rear Defogger Timer/Relay, Power Seats Powertrain Control Module (PCM), EVAP Canister Purge Vacuum Switch, EVAP Canister Purge Valve, Transmission Wiper Motor Assembly, WiperNVasher Switch Power Windows Switch (RH, LH), Express-Down Module, Coolant Level Latching Module, Convertible Top Switch

Fuse Iff DIMMER

RADIO

Usage Door Illumination Lamp (LH, RH), Headlamp Switch, Fog Lamp Switch, Instrument Cluster, HVAC Control Assembly, PRNDL Illumination Lamp, Ashtray Lamp, Radio, Steering Wheel Controls-Radio, Rear Window Defogger Switchmimer, Performance/ASR Switch Body Control Module (BCM), Radio, Amplifier, Steering Wheel Controls-Radio

6-69

Underhood Electrical Center Fuses

Fuse ABS IGN ACTUATORS

R HDLP DR L HDLP DR ABS VLV ABS BAT AIR PUMP

Usage Anti-Lock Brake System Daytime Running Lamp Module, Headlamp Switch, Cooling Fan Relay, Exhaust, Gas Recirculation, EVAP Canister Purge Solenoid Headlamp Door Module Headlamp Door Module Brake Pressure Valve Electronic Brake Control Module Air Pump (VS) Relay, Pump, Bleed Valve and Cooling Fan

The underhood electrical center fuses are located in the engine compartment. Open the cover to expose the fuses.

6-70

Fuse HORN INJECTOR ENG SEN

IGNITION

A/C-CRUISE

Usage Horn Relay Fuel Injectors Mass Air Flow, Heated Oxygen fl Sensor, Reverse Lockout Solenoid. Skip Shift Solenoid, Automatic Transmission, Brake Switch V6 VIN K: Electronic Ignition Control Module

V8 VIN P: Ignition Coil Module,

Crankshaft Position Sensor, Ignition Coil Air Conditioning Compressor Relay; Cruise Control Switches and Module

Relay

Usage Air Conditioning Compressor Anti-Lock Brake SystedTraction Control System (ASR) Cooling Fan 1 Air Pump Cooling Fan 2 Not Used Fog Lamps Cooling Fan 3

6-71

Replacement Bulbs Ashtray" ................................ 194 Automatic Transmission Indicator . . . . . . . . . . . . . 73 Back-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1141 Center High-Mounted Stoplamp . . . . . . . . . . . . . 92 1 Cluster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161 Console ................................ 194 Dome ................................ 906 ............................ 74 Door Courtesy Fog . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 885 Front Parking and Turn Signal . . . . . . . . . . . . . . 3057 GloveBox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194 Headlamp (Low-Beam) ................. H-435 1 . . . . . . . . . . . . . . . . H-4352 Headlamp (High-Beam) Heater and A/C Control . . . . . . . . . . . . . . . . . . . . . 37

High-Beam Indicator . . . . . . . . . . . . . . . . . . . . 161 .......................... 161 Indicator Lights ....................... Interior Door Handle 74 License ................................. 194 Reading ............................... 212-2 Rear Courtesy ............................ 562 Sidemarker . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194 ............................... 194 Tail Only TaiVStoplTurn .......................... 2057 Trunk .................................. 562 . . . . . . . . . . . . . . . . . . . . . 161 Turn Signal Indicators *Manual transmission only .

6-72

Capacities and Specifications Engine Type VIN Engine Code K ...................... V6 VIN Engine Code P ...................... V8 Fuel Delivery .................... Fuel Injection In-Head Valve Arrangement Piston Displacement

....................

. I

VIN Engine Code K ............ 23 1 CID (3.8L) - - 350 CID (5.7L) VIN Engine Code P ......... Firing Order VIN Engine Code K . . . . . . . . . . . . 1-6-5-4-3-2 VIN Engine Code P . . . . . . . . . 1-8-4-3-6-5-7-2 Wheel Nut Torque ........... 100 lb-ft (140 N-m) Thermostat Temperature Specification .................... Windshield Wiper Blade Replacement Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . hook Length ..................... 24 inches (610 mm)

1 80" F (82 O C)

Capacities (Approximate) The following approximate capacities are given in metric

and English conversions. /. Air Conditioning? . . . . . . . . . . . . . See the refngerant

information label under the hood.

Automatic Transmission

.............. 10 pints (4.7 L)*

Drain and Refill Overhaul VIN Engine Code K . . . . . . . . 17.6 pints (8.3 L)* VIN Engine Code P . . . . . . . 2 1.6 pints. ( 10.2 L)*

Cooling System With Manual Transmission .... 12.5 quarts (11.8 L) . . 12.3 quarts (11.6 L) With Automatic Transmission VIN Engine Code K With Manual Transmission . . 12.5 quarts (1 1.8 L) With Automatic Transmission . 12.3 quarts (1 1.6 L) VIN Engine Code P

With Manual Transmission . 15.3 quarts (14.5 L) With Automatic Transmission . 15.1 quarts. (14.3 L)

6-73

Vehicle Dimensions Length Width Height Wheelbase Front Tread Rear Tread

193.2 inches (4 908 mm) 74.1 inches (1 883 mm) 5 1.3 (1 303 mm) inches 101.1 inches (2 566 mm) 60.7 inches (1 542 m: 60.6 inches (1 540 mm)

‘

Capacities (Approximate) Crankcase . . . . . . . . . . . . . . . . . . 4.5 quarts (4.3 L)** Fuel Tank . . . . . . . . . . . . . . . . . . 15.5 gallons (58.7 L) Manual Transmission Five-Speed . . . . . . . . . . . . . . . . . 5.9 pints (2.8 L)* Six-Speed . . . . . . . . . . . . . . . . . . 8.0 pints (3.8 L)* Rear Axle Lubricant . . . . . . . . . . . . . . 3.5 pints (1.7L) ?Not all air conditioning refrigerants are the same. If the air conditioning system in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re not sure, ask your Chevrolet dealer. *Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual Transmission Fluid” in the Index. **Recheck the oil level after filling. See “Engine Oil” in the Index.

6-74

Replacement Parts Air Cleaner Filter . . . . . . . . . . . . . . . . . . . . . . A1 163C Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75-60 Engine Oil Filter

K . . . . . . . . . . .

. . . PF47 VIN Engine Code VIN Engine Code P . . . . . . . . . . . . . . . . PF25 Fuel Filter ............................. GF578 PCV Valve VIN Engine Code K . . . . . . . . . . . . . . . . . CV892C . . . . . . . . . CV895C VIN Engine Code P . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . RC24

Radiator Cap Spark Plug VIN Engine Code K . . . . . . . . . . . AC Type 4 1-60 1 (0.060” Gap) VIN Engine Code P . . . . . . . . . AC Type R45LTSP (0.050” Gap)

Air Conditioning Refrigerants Not all air conditioning refrigerants are the same. If the air conditioning system in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re not sure, ask your Chevrolet dealer.

6-75

NOTES

6-76

0 Section 7 Maintenance Schedule

IMPORTANT: KEEP ENGINE OIL AT THE PROPER

.EVEL AND CHANGE AS

RECOMMENDED

This section covers the maintenance required for your Chevrolet. Your vehicle needs these services to retain its safety, dependability and emission control performance.

Protection I

Have you purchased the GM Protection Plan? The Plan. supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or your Chevrolet dealer for details.

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to keep your vehicle in good condition, please maintain your vehicle properly.

7-1

How This Section is Organized The remainder of this section is divided into five parts: “Part A: Scheduled Maintenance Services” shows what to have done and how often. Some of these services can be ,complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and equipment for the job. If you have any doubt, have a qualified technician do the work.

If you are skilled enough to do some work on your vehicle, you will probably want to get the service information GM publishes. See “Service and Owner Publications” in the Index.

7-2

“Part B: Owner Checks and Services” tells you what should be checked whenever you stop for fuel. It also explains what you can easily do to help keep your vehicle in good condition. &‘Part C: Periodic Maintenance Inspections” explains important inspections that your Chevrolet dealer’s service department or another qualified service center should perform. (‘Part D: Recommended Fluids and Lubricants” lists some products GM recommends to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record” provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this part. This will help you determine when your next maintenance should be done. In addition, it is a good idea to keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you’ll find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your Chevrolet dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts.

The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. These schedules are for vehicles that:

carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index. are driven on reasonable road surfaces within legal driving limits. use the recommended fuel. See “Fuel” in the Index.

Selecting the Right Schedule First you’ll need to decide which of the two schedules is right for your vehicle. Here’s how to decide which schedule to follow:

7-3

Maintenance Schedule

Short TriplCity Definition Follow the Short Trip/City Maintenance Schedule if any one of these conditions is true for your vehicle:

Most trips are less than 5 to 10 miles (8 to 16 km). This is particularly important when outside temperatures are below freezing.

0 Most trips include extensive idling (such as frequent

driving in stop-and-go traffic). Most trips are through dusty areas.

0 You frequently tow a trailer or use a carrier on top of

your vehicle. If the vehicle is used for delivery service, police, taxi or other commercial application.

One of the reasons you should follow this schedule if you operate your vehicle under any of these conditions is that these conditions cause engine oil to break down soonez Short TriplCity Intervals Every 3,000 Miles (5 000 km): Engine Oil and Filter

Change (or 3 months, whichever occurs first).

Every 6,000 Miles (10 000 km): Chassis Lubrication

(or 6 months, whichever occurs first).

7-4

Short TriplCity Intervals At 6,000 Miles (10 000 km) -- Then Every

12,000 Miles (20 000 km): Tire Rotation.

Every 6,000 Miles (10 000 km) of Trailering: Rear

Axle Fluid Change (Vehicles Towing Trailers).

At the First 6,000 Miles (10 000 km): Rear Axle Fluid

Change (Limited-Slip Differential).

Every 15,000 Miles (25 000 km): Air Cleaner Filter

Inspection, if driving in dusty conditions. Automatic Transmission Service (severe conditions only).

Every 30,000 Miles (50 000 km): Air Cleaner Filter Replacement. Fuel Tank, Cap and Lines Inspection. Every 60,000 Miles (100 000 km): Engine Accessory

Drive Belt Inspection.

Every 100,000 Miles (166 000 km): Cooling System

Service (or every 60 months, whichever occurs first). Spark Plug Wire Inspection. Spark Plug Replacement. Automatic Transmission Service (normal conditions).

These intervals only summarize maintenance services. Be sure to follow the complete maintenance schedule on the following pages.

Maintenance Schedule

Follow this maintenance schedule only if none of the conditions from the Short Trip/City Maintenance Schedule is true. Driving a vehicle with a fully warmed engine under highway conditions causes engine oil to break down slowel:

Every 7,500 Miles (12 500 km): Engine Oil and Filter Change (or every 12 months, whichever occurs first). Chassis Lubrication (or every 12 months, whichever occurs first). At the First 7,500 Miles (12 500 km): Rear Axle Fluid Change (Limited-Slip Differential). At 7,500 Miles (12 500 km) -- Then Every 15,000 Miles (25 000 km): Tire Rotation. Every 15,000 Miles (25 000 km): Automatic

Transmission Service (severe conditions only).

Every 30,000 Miles (50 000 km): Air Cleaner Filter

Replacement. Fuel Tank, Cap and Lines Inspection. Every 60,000 Miles (100 000 km): Engine Accessory

Drive Belt Inspection.

Every 100,000 Miles (166 000 km): Cooling System

Service (or every 60 months, whichever occurs first). Spark Plug Wire Inspection. Spark Plug Replacement. Automatic Transmission Service (normal conditions).

These intervals only summarize maintenance services. Be sure to follow the complete maintenance schedule on the following pages.

7-5

1

- Short Trip/City Maintenance Schedule

The services shown in this schedule up to 100,000 miles (1 66 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. Footnotes

3,000 Miles (5 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

t-

7-6

ACTUAL MILEAGE SERVICED

BY:

I 9,000 Miles (15 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Short Trip/City Maintenance Schedule 6,000 Miles (10 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. 0 Change the rear axle gear lubricant if vehicle is used to pull a trailer or has limited-slip differential.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

7-7

I 15,000 Miles (25 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Seryice. 3-

0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 OF (32°C) or higher.

I Short TripKity Maintenance Schedule 12,000 Miles (20 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

.n Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever occurs first).

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE SERVICED

BY:

7-8

I Short TripKity Maintenance Schedule I

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

lfyou do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change.

18,000 Miles (30 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service. Lubricate the steering linkage (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-9

I Short Trip/City Maintenance Schedu e l 21,000 Miles (35 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

24,000 Miles (40 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever oc.curs first).

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE ACTUAL

MILEAGE

SERVICED BY:

7-10

I Short Trip/City Maintenance Schedule 27,000 Miles (45 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

30,000 Miles (50 000 km) 17 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every

6 months, whichever occurs first).

vehicle is used to pull a trailer.

I 7 Change the rear axle gear lubricant if 0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. -f

(Continued)

CI 1 1

1 Short Trip/City Maintenance Schedule 30,000 Miles (50 000 km) (Continued) 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

7-12

If you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (1 66 000 km). Manual transmission fluid doesn’t require change.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED BY:

I

Short TripKity Maintenance Schedule 33,000 Miles (55 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Con'trol Service.

36,000 Miles (60 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever occurs first).

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED B Y

DATE

ACTUAL MILEAGE

SERVICED B Y

7-13

I Short TripKity Maintenance Schedule I 39,000 Miles (65 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

42,000 Miles (70 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. 0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

7-14

I Short Trip/City Maintenance Schedule 45,000 Miles (75 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32 O C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing.

- Uses such as found in taxi, police or

delivery service.

I f you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change. 0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-15

51,000 Miles (85 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Short TripKity Maintenance Schedule I 48,000 Miles (80 000 km) 0 Change engine oil and filter (or every

3 months, whichever od;curs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever occurs first).

vehicle is used to pull a trailer.

ACTUAL MILEAGE 3 SERVICED BY:

I DATE

DATE

7-16

ACTUAL MILEAGE

SERVICED B Y

I 57,000 Miles (95 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Short Trip/City Maintenance Schedule 54,000 Miles (90 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. 0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

ACTUAL MILEAGE 1 SERVICED BY:

DATE

ACTUAL MILEAGE

DATE

SERVICED BY: I 1

7-17

1

Short TripKity Maintenance Schedule 60,000 Miles (100 000 km) [7 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every

6 months, whichever occurs first).

vehicle is used to pull a trailer.

c] Change the rear axle gear lubricant if 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 "F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

7-18

If you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn't require change.

0 Inspect engine accessory drive belt. 0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

DATE ACTUAL

MILEAGE

SERVICED BY:

I Short Trip/City Maintenance Schedu e l 63,000 Miles (105 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

66,000 Miles (110 000 km) 0 Change engine oil and- filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. 0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY: I

_ _ _ - -

7-19

I Short Trip/City Maintenance Schedule 69,000 Miles (115 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

72,000 Miles (120 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service. Lubricate the steering linkage (or every 6 months, whichever occurs first). 0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

DATE

ACTUAL MILEAGE

SERVICED B Y

DATE

ACTUAL MILEAGE

SERVICED BY:

7-20

I Short TripKity Maintenance Schedule 75,000 Miles (125 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

lJ'you do not use your vehicle under any of rhese conditions, change the fluid and.filter ( i t 100,000 miles ( I 66 000 km). Manual transmission fluid doesn't require change. 0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. 3-

DATE

ACTUAL MILEAGE

SERVICED B Y

7-21

i

I Short Trip/City Maintenance Schedule 78,000 Miles (130 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. 0 Change the rear axle gear lubricant if

vehicle is used to pull a trailer.

81,000 Miles (135 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE SERVICED

B Y

7-22

4’

-,

? .

I Short Trip/City Maintenance Schedule I 84,000 Miles (140 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever occurs first).

87,000 Miles (145 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

vehicle is used to pull a trailer.

€ ACTUAL MILEAGE 1 SERVICED B Y

DATE

ACTUAL MILEAGE

SERVICED BY:

7-23

Short Trip/City Maintenance Schedule 90,000 Miles (150 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

vehicle is used to pull a trailer.

6 months, whichever occurs first).

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32 O C) or higher.

- In hill; I or mol mtainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

I f you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change.

0 Replace air cleaner filter. An Emission Control Service.

7-24

I Short TripKity Maintenance Schedule

Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

93,000 Miles (155 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

ACTUAL MILEAGE 1

I DATE

ACTUAL MILEAGE

DATE

SERVICED BY:

7-25

u -

Short Trip/City Maintenance Schedule 96,000 Miles (160 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if

6 months, whichever occurs first).

vehicle is used to pull a trailer.

99,000 Miles (145 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED B Y

DATE

ACTUAL MILEAGE

SERVICED BY:

7-26

Short TripKity Maintenance Schedule 100,000 Miles (1 44 000 km) 0 Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test cooling system and pressure cap. An Emission Control Service. 0 Inspect spark plug wires. An Emission Control Service.

0 Replace spark plugs. 0 If you haven’t used your vehicle under

An Emission Control Service.

severe service conditions listed previously and, therefore, haven’t changed your automatic transmission fluid, change both the fluid and filter.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-27

I I Long Trip/Highway Maintenance Schedule 1

The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. Footnotes

The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or lirnit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

7-28

7,500 Miles (12 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

12 months, whichever occurs first).

0 Lubricate the steering linkage (or every 0 Change the rear axle gear lubricant if the vehicle has limited-slip differential. 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation

pattern and additional information. m

ACTUAL MILEAGE

SERVICED B Y

Long Tripmighway Maintenance Schedule 1 15,000 Miles (25 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Change automatic transmission fluid and

12 months, whichever occurs first).

filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

Ifyou do not use your vehicle under any of these conditions, change the fluid and filter at IOO, 000 miles ( I 66 000 km). Manual transmission fluid doesn’t require change.

- In hilly or mountainous terrain.

DATE

ACTUAL MILEAGE

SERVICED B Y

1 Long Tripmighway Maintenance Schedule I 22,500 Miles (37 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 12 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information.

30,000 Miles (50 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

12 months, whichever occurs first).

0 Lubricate the steering linkage (or every 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32 O C) or higher.

I DATE

I ACTUALMILEAGE

ISERVICED

B Y I

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

7-30

I Long Trip/Highway Maintenance Schedule I

I f you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change.

0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or ‘leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

37,500 Miles (62 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

12 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-31

1 Long Trip/Highway Maintenance Schedule I 45,000 Males (75 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). . An Emission Control Service. 0 Lubricate the steering linkage (or every 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:

12 months, whichever occurs first).

In heavy city traffic where the outside temperature regularly reaches 90 O F (32°C) or higher. In hilly or mountainous terrain. When doing frequent trailer towing.

7-32

- Uses such as found in taxi, police or

delivery service.

If you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Mapual transmission fluid doesn't require change.

DATE

ACTUAL MILEAGE

SERVICED BY:

I Long Tripmighway Maintenance Schedule I 52,500 Miles (87 500 km)

60,000 Miles (100 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

12 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information.

Change engine oil and filter (or every 12 months, whichever occurs first). AIZ Emission Control Service.

[7 Lubricate the steering linkage (or every 17 Change automatic transmission fluid and

12 months, whichever occurs first).

filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 “F (32°C) or higher.

1 I ACTUAL MILEAGE

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

SERVICED B Y

(Contimeal

7-33

Long Trip/Highway Maintenance Schedule I

m m

60,000 Miles (100 000 km) (Continued)

~~

If you do not use your vehicle under any of these conditions, change the fluid and filter at 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change.

0 Inspect engine accessory drive belt. 0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

67,500 Miles (112 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 12 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED B Y

DATE

ACTUAL MILEAGE

SERVICED BY

7-34

I Long TripBighway Maintenance Schedule I 75,000 Miles (125 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service. Lubricate the steering linkage (or every 12 months, whichever occurs first). 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- Uses such as found in taxi, police or

delivery service.

I f you do not use your vehicle under any of these conditions, change the fluid andfilter ut 100,000 miles (166 000 km). Manual transmission fluid doesn’t require change.

- In hilly or mountainous terrain. - When doing frequent trailer towing.

DATE

ACTUAL MILEAGE

SERVICED B Y

7-35

Long Tripmighway Maintenance Schedule 82,500 Miles (137 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the steering linkage (or every 0 Rotate tires. See “Tire Inspection and

12 months, whichever occurs first).

Rotation’’ in the Index for proper rotation pattern and additional information.

DATE

.ACTUAL MILEAGE

SERVICED BY:

I -36

90,000 Miles (150 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

12 months, whichever occurs first).

0 Lubricate the steering linkage (or every 0 Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90°F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

~~~~

I Long Trip/Highway Maintenance Schedule I 97,500 Miles (162 500 km) 0 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

lf you do not use your vehicle under any of these conditions, change the fluid and jilter at 100,000 miles ( I 66 000 km). Manual transmission fluid doesn’t require change.

0 Replace air cleaner filter.